Bradley S19-210FW Bedienungsanleitung

P.O. Box 309, Menomonee Falls, WI USA 53052-0309

PHONE 1-800-BRADLEY FAX (262) 251-5817

http://www.bradleycorp.com

Installation

215-155FW Rev. F; EN 06-532D

Page 1 of 4 6/20/07

S19-210FW

Pedestal-Mounted Eye/Face Wash

Table of Contents

Pre-Installation Information . . . . . . . . . . . . . . . . . . . . . .2

Installation Instructions . . . . . . . . . . . . . . . . . . . . . . . . .3

Assembly of Components . . . . . . . . . . . . . . . . . . . . . . .4

Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

S19-210FW Installation

6/20/07 Bradley Corporation • 215-155FW Rev. F; EN 06-532D

WARNING

Read this installation manual completely to ensure proper installation, then file it

with the owner or maintenance department. Compliance and conformity to drain

requirements and other local codes and ordinances is the responsibility of the

installer.

Separate parts from packaging and make sure all parts are accounted for before

discarding any packaging material. If any parts are missing, do not begin

installation until you obtain the missing parts.

Flush the water supply lines before beginning installation and after installation is

complete. Test the unit for leaks and adequate water flow. Main water supply to

the eyewash should be “ON” at all times. Provisions shall be made to prevent

unauthorized shutoff.

The ANSI Z358.1 standard requires an uninterruptible supply of flushing fluid at a

minimum 30 PSI (0.21 MPa) flowing pressure. Flushing fluid should be tepid per

ANSI Z358.1.

The inspection and testing results of this equipment should be recorded weekly

to verify proper operation. This equipment should be inspected annually to

ensure compliance with ANSI Z358.1.

Workers who may come in contact with potentially hazardous materials should be

trained regarding the placement and proper operation of emergency equipment

per ANSI Z358.1.

For questions regarding the operation or installation of this product, visit

www.bradleycorp.com or call 1-800-BRADLEY.

Product warranties may also be found under ”Product Information” on our web

site at www.bradleycorp.com.

Installation

THIS

SIDE

Packing List

P.O.Box309, MenomoneeFalls, WI 53051

TESTTHISUNITEACHWEEK

Test-operatevalve(s) each week and sign below.

Reportany malfunctions immediately.

Ventil(e)wöchentlich im Testbetrieb prüfen, bestätigt

durchUnterschrift. Jegliche Störung sofort melden.

Date

Datum

Date

Signed

Unterschrift

Signe

Date

Date Signed

Signed

DIESESGERÄT1STWÖCHENTLICHZUPRÜFEN.

ESSAIHEBDOMADAIRE

Testle fonctionnement des valves chaque semaine et

signeen bas. S'il y à quelque chose qui ne va pas fait

unrapport immédiatement.

P.O.BOX309, MENOMONEE FALLS,WI 53052-0309 USA

TEL:1-800-BRADLEY FAX:(262-251-5817)

http://www.bradleycorp.com

114-051

Installation S19-210FW

Bradley Corporation • 215-155FW Rev. F; EN 06-532D 6/20/07

Installation

Supplies Required:

• (3) 3/8" floor anchors and bolts

• Pipe sealant

• Piping to 1/2" IPS water supply inlet on unit

• Piping to 1-1/4" IPS drain outlet for eye/face

wash

• Sign-mounting hardware

NOTE: Flush the water supply line before

beginning installation.

Step 1: Secure base to floor

1. To secure base to floor, install three suitable

anchors (supplied by installer) for 3/8" bolts

in the floor (Figure 1).

2. Bolt the base to the floor anchors using 3/8"

bolts (supplied by installer).

Step 2: Assemble eye/face wash

1. Assemble eye/face wash components as

shown in Figure 2 on page 4.

• Apply pipe sealant (supplied by installer)

to all male-threaded pipe joints.

• Use the rubber grip pad provided or a strap

wrench around pipes when tightening to

prevent marring. Place the grip pad on the

pipe, then put the wrench over the grip pad

and turn the pipe with the wrench.

Step 3: Connect water supply

1. Connect the water supply piping (supplied by

installer) to the 1/2" IPS inlet.

2. Connect the drain piping (supplied by

installer) to the 1-1/4" IPS drain outlet.

3. Mount the safety sign to the wall using sign-

mounting hardware (supplied by installer).

4. Open the water supply lines and test for

leaks and adequate water flow.

15-1/2" (394mm)

42-5/8"

(1082mm)

5-1/4"

(133mm)

36"

(914mm)

Ø 10"

(254mm)

(152mm)

8-3/8"

(212mm)

Figure 1

NOTE: All dimensions assume standard thread

engagement. Variations in manufacturing allow

for +/- 1/8" (3mm) per threaded joint. To find

the tolerance of a dimension, add the number

of thread joints in between a dimension and

multiply it by 1/8" (3mm).

Assembly of Components

S19-210FW Installation

6/20/07 Bradley Corporation • 215-155FW Rev. F; EN 06-532D

P.O. Box 309, Menomonee Falls, WI 53051

TEST THIS UNIT EACH WEEK

Test-operate valve(s) each week and sign below.

Report any malfunctions immediately.

Ventil(e) wöchentlich im Testbetrieb prüfen, bestätigt

durch Unterschrift. Jegliche Störung sofort melden.

Date

Datum

Date

Signed

Unterschrift

Signe

Date

Date Signed

Signed

DIESES GERÄT 1ST WÖCHENTLICH ZU PRÜFEN.

ESSAI HEBDOMADAIRE

Test le fonctionnement des valves chaque semaine et

signe en bas. S'il y à quelque chose qui ne va pas fait

un rapport immédiatement.

P.O.BOX 309,MENOMONEE FALLS, WI 53052-0309 USA

TEL:1-800-BRADLEY FAX:(262-251-5817)

http://www.bradleycorp.com

114-051

5.3

5.1

4.5

4.4

4.3

4.2

4.1

1/2" IPS

Supply Inlet

1-1/4" IPS

Drain Outlet

8.1

5.2

NOTE: Items 4 and 5 come preassembled.

Figure 2

1 131-059 1 Base

2 169-727 1 Pipe Tee 1-1/4"

3 113-006LC 1 Pipe 1-1/4" x 27-1/2"

4 S90-095 1 Eye/Face Wash Assembly

4.1 111-039 1 Inlet Drain Fitting

4.2 124-028 1 Center Seal Gasket

4.3 154-058 1 Plastic Eye/Face Wash Bowl

4.4 173-025 1 Cup Strainer

4.5 113-1150 1 Stem Pipe

5 S05-064D 1 Eye/Face Wash Assembly

5.1 S05-091P 1 Eye/Face Wash Yoke

5.2 S05-135 2 Eye/Face Wash Head

5.3 S53-063 2 Tethered Dust Cover

6 113-006LQ 1 Pipe 1/2" x 3-1/2"

7 169-025 1 Street Elbow 1/2"

8 S27-282 1 1/2" Ball Valve w/Nut

8.1 110-215 1 Nut Only

9 128-135 1 Plastic Handle

10 142-002DA 1 Lockwasher

11 114-051 1 Safety Sign

12 204-421 1 Emergency Inspection Tag

13 269-915 1 Grip Pad (not shown)

Item Part No. Qty Description

Prepack S45-122 includes Items 8, 8.1, 9, 10

Prepack S45-123 includes Items 8.1, 9, 10

Andere Handbücher für S19-210FW

Andere Bradley Sanitärprodukte Handbücher

Bradley

Bradley Express SS-3 Infrared-to-Touch Time Bedienungsanleitung

Bradley

Bradley MG Series Bedienungsanleitung

Bradley

Bradley S19294 Series Bedienungsanleitung

Bradley

Bradley SN2003 Kurzanleitung

Bradley

Bradley S19-690 Bedienungsanleitung

Bradley

Bradley S19-220FW Bedienungsanleitung

Bradley

Bradley S19-230H Bedienungsanleitung

Bradley

Bradley Terrazzo WF2613 Bedienungsanleitung

Bradley

Bradley S19-270C Bedienungsanleitung

Bradley

Bradley S19-220DC Bedienungsanleitung

Bradley

Bradley MF2939/BIR3 Bedienungsanleitung

Bradley

Bradley S19-120FM Bedienungsanleitung

Bradley

Bradley S19-125BF Bedienungsanleitung

Bradley

Bradley P19-234 Bedienungsanleitung

Bradley

Bradley TDB3108 Bedienungsanleitung

Bradley

Bradley Express ELX Series Bedienungsanleitung

Bradley

Bradley S19294 Series Bedienungsanleitung

Bradley

Bradley S19-230T Bedienungsanleitung

Bradley

Bradley 1WCA-BF Bedienungsanleitung

Bradley

Bradley Express MG Series Bedienungsanleitung

Bradley

Bradley Express Crescent CRS-2/IR Bedienungsanleitung

Bradley

Bradley WS-1X Bedienungsanleitung

Bradley

Bradley Equa-Flo Pressure Balancing Valve Bedienungsanleitung

Bradley

Bradley Terreon Deep Bowl WF3200 Series Bedienungsanleitung

Beliebte Sanitärprodukte Handbücher anderer Marken

Weka

Weka 506.2020.00E Betriebsanleitung

American Standard

American Standard DetectLink 6072121 Bedienungsanleitung

Kohler

Kohler K-6228 Montageanleitung

Uponor

Uponor Contec TS Bedienungsanleitung

Pfister

Pfister Selia 49-SL Bedienungsanleitung

Fortis

Fortis VITRINA 6068700 Bedienungsanleitung

Kohler

Kohler K-12183 Montageanleitung

Maxxus

Maxxus MX-M206-01 Bedienungsanleitung

Viega

Viega Prevista Pure 8512 Bedienungsanleitung

Kohler

Kohler Centerset K-15240 Montageanleitung

Viega

Viega Prevista Dry 8522.33 Bedienungsanleitung

Sanela

Sanela Lema SLP 59RB Bedienungsanleitung

Elkay

Elkay EDF15AC Installationshandbuch

Hans Grohe

Hans Grohe AXOR Citterio E 36702000 Handbuch

baliv

baliv WT-140 Bedienungsanleitung

Kohler

Kohler Mira Eco Bedienungsanleitung

BELLOSTA

BELLOSTA romina 0308/CC Bedienungsanleitung

Bristan

Bristan PS2 BAS C D2 Verdrahtungsschema