Elkay 4430 Bedienungsanleitung

PAGE 1 1000004244 (Rev. B - 01/18)

4430_FTN _A LK4430_FTN_A

4430 Fountains are among the easiest to install Fountains on the market today.

To assure you install these models easily and correctly, PLEASE READ THESE

SIMPLE INSTRUCTIONS BEFORE STARTING THE INSTALLATION. CHECK YOUR

INSTALLATION FOR COMPLIANCE WITH PLUMBING, ELECTRICAL, AND OTHER

APPLICABLE CODES. After installation, leave these instructions with the Fountain for

future reference.

Owners Manual

Model 4430

Tri-Level Tubular Fountain

IMPORTANT

ALL SERVICE TO BE PERFORMED BY AN AUTHORIZED SERVICE PERSON

IMPORTANT! INSTALLER PLEASE NOTE.

THE GROUNDING OF ELECTRICAL EQUIPMENT SUCH AS TELEPHONE, COMPUTERS, ETC. TO WATER LINES

IS A COMMON PROCEDURE. THIS GROUNDING MAY BE IN THE BUILDING OR MAY OCCUR AWAY FROM

THE BUILDING. THIS GROUNDING CAN CAUSE ELECTRICAL FEEDBACK INTO A FOUNTAIN, CREATING AN

ELECTROLYSIS WHICH CAUSES A METALLIC TASTE OR AN INCREASE IN THE METAL CONTENT OF THE

WATER. THIS CONDITION IS AVOIDABLE BY USING THE PROPER MATERIALS AS INDICATED. ANY DRAIN

FITTINGS PROVIDED BY THE INSTALLER SHOULD BE MADE OF PLASTIC TO ELECTRICALLY ISOLATE THE

FOUNTAIN FROM THE BUILDING PLUMBING SYSTEM.

INSTALLER

PAGE 21000004244 (Rev. B - 01/18)

4430_FTN _A LK4430_FTN_A

LEGEND

A = 3/8" O.D. UNPLATED COPPER TUBE CONNECT - SHUT OFF VALVE BY OTHERS

B = ACCESS PANEL ( 8" X 10" )

C = REMOVABLE BOTTOM COVER

1-1/2"

DRAIN

22 1/4"

565mm

28 9/16"

726mm

29 11/16"

754mm

19"

483mm

19"

483mm

8 3/16"

207mm

2 5/8"

67mm

2 5/8"

67mm

48"

1219mm

27 1/8"

689mm

33 7/16"

850mm

34 9/16"

878mm

41 7/16"

1053mm

2 5/8"

67mm

10"

254mm

203mm

30"

762mm

O14"

356mm

O12"

305mm B.C.

O1/2"

13mm (6 PL)

PAGE 3 1000004244 (Rev. B - 01/18)

4430_FTN _A LK4430_FTN_A

1. This fountain is to be mounted on a smooth, at, nished surface with adequate support structure. NOTE: Mounting

structure must be capable of supporting 300 lb. load on fountain.

2. Refer to rough-in for plumbing.

3. Install shut-off valve on water supply. (Valve not furnished)

4. Locate and install fountain using 3/8" minimum fasteners. (Fasteners not furnished).

5. Connect fountain to supply line with a shut-off valve and install a 3/8" unplated copper water line between the valve and the

cooler. Remove any burrs from outside of water line. Push the tubes straight into the ttings until they reach a positive stop,

approximately 3/4" (See Fig. 2). DO NOT SOLDER TUBES INSERTED INTO THE STRAINER AS DAMAGE TO THE

O-RINGS MAY RESULT.

6. Water supply 3/8" O.D. unplated copper tube. Waste 1-1/2" IPS. Contractor to supply waste trap and service stop valve in

accordance with local code.

7. Connect water supply and fountain drain. Connect drain waste "Tee" to fountain drain tubes. Connect outlet of "Tee" to

drainage system. Water connection and drain must comply with local codes.

8. Turn on water supply and check all connections for leaks. Threaded drain ttings may require thread sealer to create a

leak free connection. Apply thread sealer to threaded connection ttings only, not the slip connection ttings.

CAUTION: This fountain is rated for inlet water pressure of 20-105 PSI. A pressure reducing regulator should be used if the

inlet water supply exceeds 105 PSI. Any damage caused by reason of connecting this product to supply line pressures

lower than 20 PSI or higher than 105 PSI is not covered by warranty.

9. Connecting lines to be made of unplated copper and should be thoroughly ushed to remove all foreign matter before being

connected

to fountain. This fountain is manufactured in such a manner that it does not in any way cause taste, odor, color, or sediment

problems.

Actuation of Quick Connect Water Fittings:

Fountain is provided with lead-free connectors which utilize an

o-ring water seal. To remove tubing from the tting, relieve water

pressure, push in on the gray collar while pulling on the

tubing.(see Fig.2) To insert tubing, push tube straight into tting

until it reaches a positive stop, approximately 3/4".

TROUBLE SHOOTING AND MAINTENANCE

STREAM HEIGHT ADJUSTMENT:

Stream height is factory set at 35 PSI. If supply pres-

sure varies greatly from this, insert a small straight

bladed screwdriver through the access hole in the

center of the push button and turn the adjustment

screw. Clockwise adjustment will raise the stream and

counterclockwise adjustment will lower the stream.

For best adjustment, the stream should be approxi-

mately 1 1/2" above the top of the bubbler . (See Fig.

3).

FIG. 3

FIG. 1

1/4” O.D. TUBE

WATER INLET

TO COOLER

3/8” O.D. TUBE CONNECT

COLD WATER SUPPLY

BUILDING WATER

INLET

NOTE: WATERFLOW

DIRECTION

SERVICE STOP

(NOT FURNISHED)

FIG. 2

B CA

SIMPLY PUSH IN

TUBE TO ATTACH

TUBE IS SECURED

IN POSITION

PUSH IN COLLET

TO RELEASE TUBE

OPERATION OF QUICK CONNECT FITTINGS

PUSHING TUBE IN BEFORE

PULLING IT OUT HELPS TO

RELEASE TUBE

OPERATION OF QUICK CONNECT FITTINGS

SIMPLY PUSH IN

TUBE TO ATTACH

TUBE IS SECURED

IN POSITION

PUSH IN COLLET

TO RELEASE TUBE

PUSHING TUBE IN BEFORE

PULLING IT OUT HELPS TO

RELEASE TUBE

A B C

PAGE 41000004244 (Rev. B - 01/18)

4430_FTN _A LK4430_FTN_A

Vandal-Resistant Bubbler

FIG. 4

BASIN

PRINTED IN U.S.A.

ITEM

NO.

PART NO.

98684C

28467C

0000000325

98530C

97446C

55996C

66346C

40551C

98683C

70852C

97247C

1000003812*

1000003813*

45734C

98682C

1000003694

1000003695

56092C

ITEMIZED PARTS LIST

Kit - Drain Elbow/Gasket/Nut/Washer

Basin

Kit - Drain Plug & Gasket

Kit - Regulator/Holder/Nut

Kit - Bubbler (VR)

In - Line Strainer

Drain Tube

Tailpipe

Kit - Drain Adapter/Gasket/Nut/Washer

Tee - 3/8"

Kit - VR Torx Screws/Bit

Access Panel

Bottom Cover

Drain Tube

Kit - Push Button w/Blank Nameplate

Kit - Push Button w/LK4430 Nameplate

Kit - Push Button w/4430 Nameplate

Poly Tubing (Cut To Length)

DESCRIPTION

11 (4)

16 6

11 (4)

See Fig. 3

FOR PARTS CONTACT YOUR LOCAL DISTRIBUTOR OR CALL 1.800.834.4816

*select color option to complete part number

PRINTED IN U.S.A.

Halsey Taylor – halseytaylor.com

Elkay – elkay.com

*FINISH COLOR OPTIONS – Choose color option to

complete your model number, add as sufx example:

4430EVG

Matte nish: Evergreen = EVG

Gloss nish:

Beige = BGE Gray = GRY Terracotta = TER

Black = BLK Orange = ORN White = WHT

Blue = BLU Purple = PUR Yellow = YLW

Brown = BRN Red = RED

11 (4)

11 (4) 13

Inhaltsverzeichnis

Andere Elkay Freiluftbrunnen Handbücher

Elkay

Elkay EWCDA B Series Installationshandbuch

Elkay

Elkay FLEXI-GUARD EFW16 1E Series Installationshandbuch

Elkay

Elkay SWIRLFLO ENOBM28K Gebrauchsanweisung

Elkay

Elkay ERPA8C*A Installationshandbuch

Elkay

Elkay HEWD K Series Installationshandbuch

Elkay

Elkay Soft Sides ERO8C C Series Installationshandbuch

Elkay

Elkay 4400DBFR Bedienungsanleitung

Elkay

Elkay ERPA8C Installationshandbuch

Elkay

Elkay SWIRLFLO FLEXI-GUARD ERPB8C 2C Series Installationshandbuch

Elkay

Elkay 4420FR FTN A Series Bedienungsanleitung

Elkay

Elkay LVRCTL8 1D Series Installationshandbuch

Elkay

Elkay 4420 Series Bedienungsanleitung

Elkay

Elkay SWIRLFLO EDFPBWM114C Gebrauchsanweisung

Elkay

Elkay EDFP19C series Installationshandbuch

Elkay

Elkay 4410BFFR Bedienungsanleitung

Elkay

Elkay SOFT SIDES EZLMSN-EDFPVM217DK Gebrauchsanweisung

Elkay

Elkay FLEXI-GUARD ESRC8,13 1D Series Installationshandbuch

Elkay

Elkay Soft Sides ERO8C-C Installationshandbuch

Elkay

Elkay 4400BFEVGWR Installationshandbuch

Elkay

Elkay SWIRLFLO EZWS-EDFPBM114K Installationshandbuch

Elkay

Elkay EFRC8CDC-A Installationshandbuch

Elkay

Elkay LZO8WSS2KWN Bedienungsanleitung

Elkay

Elkay SWIRLFLO FLEXI-GUARD ezH2O EZWS-EDFPBM117K Gebrauchsanweisung

Elkay

Elkay Halsey Tailor 4400DB Bedienungsanleitung

Beliebte Freiluftbrunnen Handbücher anderer Marken

Sunnydaze Decor

Sunnydaze Decor XSS-578 Bedienungsanleitung

Campania International

Campania International Bibendum FT-400 Bedienungsanleitung

S.R.Smith

S.R.Smith Color Light Stream 2CLSLBK Bedienungsanleitung

Hozelock Cyprio

Hozelock Cyprio Cascade 1500 Bedienungsanleitung

Campania International

Campania International Juliet Fountain Bedienungsanleitung

YARDART

YARDART FT-155 Bedienungsanleitung

Alpine

Alpine WIN732 Bedienungsanleitung

Campania

Campania Valencia Bedienungsanleitung

Campania International

Campania International FT-320 Bedienungsanleitung

GardenWize

GardenWize SWGSL230 Bedienungsanleitung

Kelkay

Kelkay Easy Fountain Rustic Windmill Bedienungsanleitung

Alpine

Alpine WIN258 Bedienungsanleitung

Bond

Bond Signature Series Bedienungsanleitung

Kenroy Home

Kenroy Home 51112COPBL Installationsanleitung

EasyPro

EasyPro Tranquil Décor HBB39 Bedienungsanleitung

Angelo Decor

Angelo Decor Castillo Bedienungsanleitung

Campania International

Campania International Girona FT-102A Bedienungsanleitung

Campania International

Campania International FT-271 Bedienungsanleitung