Extech Instruments HD755 Bedienungsanleitung

USERGUIDE



HeavyDuty

DifferentialPressureManometer



ModelHD755



HD755-EU-EN V1.7 7/13

Introduction

CongratulationsonyourpurchaseoftheExtechManometerModelHD755.Thisdevicemeasures

gaugeanddifferentialpressureintherangeof±0.500psi.TheHD755offerseleven(11)unitsof

measure(userselectablebyfrontpanelpushbutton)andhasadifferentialinputthatuses

convenientquick‐disconnectfittings.AdvancedfeaturesincludeDATAHOLD,MIN‐MAX‐AVG

RECORDmode,ZERO/OFFSET,AUTOPOWEROFF,andUSBPCinterface.Thismeterisshippedfully

testedandcalibratedand,withproperuse,willprovideyearsofreliableservice.Pleasevisitour

website(www.extech.com)tocheckforthelatestversionofthisUserGuide,ProductUpdates,and

CustomerSupport.



MeterDescription

1. P1input

2. ACadaptorjack

3. P2Input

4. LCDDisplay–Indicatesthemeasurementdata,unitofmeasure,

elapsedtimer,andfunctionsymbolsasdescribedinthismanual

5. USBPCinterfacejack(3.5mm)–Forusewithdataacquisition

software

6. UNITbutton–Presstoselecttheunitofmeasure

7. DIFbutton–Presstodisplaydifferentialpressure.Alsousedto

OFFSETthedisplayedreadings.

8. RECORDbutton–PresstoaccesstheMIN/MAX/AVGrecording

mode

9. HOLD/ZERObutton–Presstofreezethedisplayedreading.Also

usedtozerothedisplay(pressandholduntildisplayshowsallzeroes).

10. BACKLIGHT button–PresstoswitchthedisplaybacklightON.Thebacklightwill

automaticallyturnOFFafter40seconds.

11. POWERbutton–PresstoturnthemeterONorOFF

12. Batterycompartment(onrear)



HD755-EU-EN V1.7 7/13

Display

1. USBdataoutputactive

2. DifferentialPressureMode

3. DataHoldMode

4. Primarydisplay

5. RecordMode

6. MAX/MIN/AVGindicators

7. LowBatteryIndicator

8. Pressureunitofmeasure

9. ElapsedTimer

HD755-EU-EN V1.7 7/13

BasicOperation

MeterPower

TheHD755usesa9Vbatteryforpower.IfthemeterdoesnotswitchonwhenthePOWER

buttonispressedorifthedisplayshowsBAT,replacethebattery.

WhenthePOWERbuttonsispressed,themeterperformsashortself‐testandrevertstothe

settingsinplacewhenthemeterwaslastturnedoff.

AutomaticPower‐offFeature

Inordertoconservebatterylife,themeterhasanautomaticpowerofffeature(after20

minutes).Todefeatthisfeature,pressandholdtheHOLDbuttonwhileturningthemeteron.

ReleasetheHOLDbuttonwhen‘n’appearsonthedisplay.Themeterwillnowremainonuntil

theuserturnsitofforuntilthebatteryweakens.NotethattheAutoPowerOFFfeaturewillbe

reactivatedthenexttimethemeteristurnedoffandthenon.

UnitofMeasure

PresstheUNITbuttontoselecttheunitofmeasure.Thismeterofferseleven(11)unitsof

measureaslistedbelow.



UnitofMeasureDisplayicon

Poundspersquareinchpsi

InchesofMercuryinHg

Milli‐barmbar

MillimetersofMercurymmHg

Kilo‐PascalskPa

KilogramspercentimetersquaredKgcm2

InchesofwaterinH2O

FeetofwaterftH2O

CentimetersofwatercmH2O

BarsBar

Ouncespersquareinchozin2



FittingsConnection

ConnecttubingtotheP1,P2(orboth)inputport(s).Ifbothinputsareused(differentialmode),

themeterdisplaysapositivepressurereadingiftheP1pressureisgreaterthanP2anda

negativereadingifP2isgreaterthanP1.



HD755-EU-EN V1.7 7/13

ZeroAdjustandOffsetfunction

TheunitmustbekeptintheuprightpositionwhenZEROINGorwhentakingmeasurements.To

ZEROthemeter:Beforeuseandwithoutfittingsattachedtothemeter,pressandholdtheHOLD

buttonfor3secondsoruntilthedisplayshowsallzeroes.



ToOFFSETmeterreadings:PresstheDIFbuttonwhiletakingameasurement.Subsequent

readingswillrepresentthedifferencebetweenthecurrentmeasurementandthemeasurement

thatwasonthedisplaywhentheDIFbuttonwaspressed..PresstheDIFbuttonagaintoexitthe

OFFSETfunction.

MIN‐MAX‐AVGRecordModewithElapsedTimer

TheRECORDfunctiontracksthemaximum(MAX),minimum(MIN),andaverage(AVG)readings

withatimestamp.Theelapsedtimerisdisplayedonthelowerright‐handcorneroftheLCDand

informstheuserofthetimeaMAXorMINreadingwasrecorded.

1. PresstheRECORDbuttononce.TheRECindicatorwillappearonthedisplayandthe

displayedelapsedtimerwillstart(HH:MM:SSformat[hours:minutes:seconds]).

2. PresstheRECORDbuttonagaintoviewthehighest(MAX)readingrecordedsincethe

RECORDbuttonwasfirstpressed.TheMAXindicatorandmaximumreadingwillappearon

thedisplay.TheelapsedtimerwillshowthetimeoftheMAXevent.

3. PresstheRECORDbuttonagain,theMINindicatorandtheminimumvaluewillappearon

thedisplay.TheelapsedtimerwillshowthetimeoftheMINevent.

4. PresstheRECORDbuttonagain,theAVGindicatorandtheaveragevaluewillappearonthe

display.Theelapsedtimerwillcontinuetorun.

5. Toreturntonormaloperation,pressandholdtheRECORDbuttonuntilthedisplay

indicatorsREC,MAX,etc.switchoff.

NotethatintheRECORDmode,thebacklightandthepowerbuttonsaretheonlyavailable

functions.

USBPCInterface

Themeterhasabuilt‐inUSBportforusewiththeManometerDataAcquisitionsoftware.The

softwareallowstheusertoview,save,export,andprintreadingsfromtheHD755.Refertothe

documentationincludedwiththesoftwareforcompletedetails.

DisplayedErrorCodes

Thefollowingcodesaredisplayedwhenthemeterencountersanerror.

ERR1:Pressureinputexceedsspecifiedlimits

ERR2:Pressureinputistoolowtoread

ERR3:TheDifferentialPressureinputexceedsspecifiedlimits

ERR4:TheDifferentialPressureinputistoolowtoread

HD755-EU-EN V1.7 7/13

Specifications

GeneralSpecifications

DisplayFourdigitLCDwithfunctionindicators

UnitsofMeasureBAR,mBAR,psi,kg/cm2,mmHg,inchesHg,kPa,feetH2O,inches

H2O,cmH2O,andozin2

Accuracy±0.3%FS+1d(@25°C)

Repeatability±0.2%to0.5%FS

Linearity/Hysteresis±0.3%FS

CombinedAccuracy±1.1%FS

MaximumPressure2psi

Responsetime0.5stypical

InputcircuitDifferentialinputs(P1andP2)

InputPortsTwometal4.8mm,barbedfor1/8"(3.17mm)IDtubing

DataHoldFreezesdisplayedreading

SensorBuilt‐inpiezoelectricsensors

Zero/OffsetfunctionPushbuttonactivation

Samplerate0.5sec.(approx.)

CompatibilityAirornon‐corrosiveandnon‐ionizedgas(notintendedforusewith

liquids)

AutoPowerOFFMeterturnsoffafterapprox.20minutestoconserveenergy(can

bedeactivated)

PCInterfaceBuilt‐inUSBserialinterface

Storageconditions0to60oC(14to140oF);<80%RH

Operatingconditions0to50oC(32to122oF);<80%RH

Batterypower9Valkalinebattery(BATlowbatteryindicator)

Batterylife125hourstypical

Dimensions210x75x50mm(8.2x2.9x1.9”)

Weight280g(9.8oz)

HD755-EU-EN V1.7 7/13

RangeSpecifications

Range/Units(Max.)Resolution

±0.034bar0.001

±34.47mbar0.01

±0.500psi0.001

±0.035Kg/cm20.001

±25.86mmHg0.01

±1.018inchesHg0.001

±3.447kPa0.001

±1.154feetH2O0.001

±13.85inchesH2O0.01

±35.15cmH2O0.01

±8.00ozin20.01



BatteryReplacement

WhenthelowbatteryindicatorBATappearsonthedisplayorifthemeterdoesnotswitchon

whenthePOWERbuttonispressed,itisnecessarytoreplacethebattery.

Toreplacethebattery:

1. Openthebatterycompartmentbyslidingthemeter’srearpanelinthedirectionofthe

embossedarrow.

2. Replacethe9Valkalinebattery

3. Replacethebatterycompartmentcover.



AllEUusersarelegallyboundbytheBatteryOrdinancetoreturnallusedbatteriesto

communitycollectionpointsorwhereverbatteries/accumulatorsaresold.

Disposalinhouseholdtrashorrefuseisprohibited.

Disposal:Followthevalidlegalstipulationsinrespectofthedisposalofthedeviceatthe

endofitslifecycle



OtherBatterySafetyReminders

Neverdisposeofbatteriesinafire.Batteriesmayexplodeorleak.

Nevermixbatterytypes.Alwaysinstallnewbatteriesofthesametype.



Warning: Pressure inputs of 10 psi or higher will damage the instrument. Do not

apply pressure higher than the maximum pressure listed in the specification table

HD755-EU-EN V1.7 7/13

Conversions

UsefulconversionFactors

FromToMultiplier

inofH2OinofHg0.07355

inofH2OcmofH2O2.54

mmofHginofH2O0.03937



Allrightsreservedincludingtherightofreproductioninwholeorinpartinanyform

ISO‐9001Certified

www.extech.com



Inhaltsverzeichnis

Andere Extech Instruments Messgerät Handbücher

Extech Instruments

Extech Instruments HD700 Bedienungsanleitung

Extech Instruments

Extech Instruments MA435T Bedienungsanleitung

Extech Instruments

Extech Instruments SL130W Bedienungsanleitung

Extech Instruments

Extech Instruments SL510 Bedienungsanleitung

Extech Instruments

Extech Instruments 407750 Bedienungsanleitung

Extech Instruments

Extech Instruments PQ2071 Bedienungsanleitung

Extech Instruments

Extech Instruments MA150-T Bedienungsanleitung

Extech Instruments

Extech Instruments TachIR RPM10 Bedienungsanleitung

Extech Instruments

Extech Instruments MA1500 Bedienungsanleitung

Extech Instruments

Extech Instruments 45158 Bedienungsanleitung

Extech Instruments

Extech Instruments 461750 Bedienungsanleitung

Extech Instruments

Extech Instruments HDV7C-55-HD-1 Bedienungsanleitung

Extech Instruments

Extech Instruments AN400 Bedienungsanleitung

Extech Instruments

Extech Instruments 461995 Bedienungsanleitung

Extech Instruments

Extech Instruments HD300-NISTL Bedienungsanleitung

Extech Instruments

Extech Instruments MA150 Bedienungsanleitung

Extech Instruments

Extech Instruments HT200 Bedienungsanleitung

Extech Instruments

Extech Instruments 406800 Bedienungsanleitung

Extech Instruments

Extech Instruments CO230 Bedienungsanleitung

Extech Instruments

Extech Instruments 381235 Bedienungsanleitung

Extech Instruments

Extech Instruments TKG100 Bedienungsanleitung

Extech Instruments

Extech Instruments BT100 Bedienungsanleitung

Extech Instruments

Extech Instruments HD450 Bedienungsanleitung

Extech Instruments

Extech Instruments 380801 Bedienungsanleitung

Beliebte Messgerät Handbücher anderer Marken

Suaoki

Suaoki D40 Bedienungsanleitung

Elster

Elster BK-G1.6 Bedienungsanleitung

Endress+Hauser

Endress+Hauser Deltabar FMD71 Handbuch

Duratool

Duratool D03128 Bedienungsanleitung

Vega

Vega VEGAPULS 65 Bedienungsanleitung

Tonghui

Tonghui TH2618B Bedienungsanleitung

Tenmars

Tenmars TM-801 Bedienungsanleitung

MSR

MSR 145 Bedienungsanleitung

TPS

TPS WP-82 Bedienungsanleitung

ELMETRON

ELMETRON CP-511 Bedienungsanleitung

PCB Piezotronics

PCB Piezotronics 003C30 Bedienungsanleitung

Tenma

Tenma 72-10465 Bedienungsanleitung

Endress+Hauser

Endress+Hauser Proline Promag 50 Technische Daten

Siemens

Siemens SITRANS F Coriolis FCT030 Stücklistenhandbuch

KLINGER

KLINGER CMF V Series Bedienungsanleitung

EXFO

EXFO FTB-2 Bedienungs- und Wartungshandbuch

Keysight

Keysight M8290A Bedienungsanleitung

ADTEK

ADTEK MW-5 Bedienungsanleitung