Keys Fitness ST-IB Bedienungsanleitung

215-00219

08/07 Rev A

Owner’s Manual

SERIAL TAG IS LOCATED ON THE FRAME

Model Name: ST-IB

Date of Purchase:

Serial Number:

International

Bench

Customer Service

(888) 340-0482

4009 Distribution Drive

Suite 250

Garland, TX 75041

www.keysfitness.com

Important Safety Information 3

Assembly 4

Getting Started 4

Hardware Identifier 5

Assembly Steps 6

Adjustments 16

Seat Adjustments 16

Backrest Adjustment 16

Attachments 17

Curl Bar 17

Olympic Plate Adapter 17

Arm Curl Post 18

Weight Rests and Safety Spotters 18

Warm Up Exercises 19

Parts List 22

Exploded Views 23

Warranty 25

Table of Contents

Important Safety Information

Please read all instructions carefully before using this product.

SAFETY TIPS

Consult with your physician before engaging in any vigorous exercise. Know your heart rate

and/or pulse as well as your physician-recommended heart rate training zone. Proper medical

clearance is recommended for anyone beginning an exercise program especially if you are 35

years of age or older or suffer from heart respiratory problems.

- Warm-up before any exercise program with 8 minutes of aerobic-like activity followed

by stretching from head to toe.

- Wear comfortable clothes that allow freedom of movement and are not tight or

restricting.

- Wear comfortable shoes made with good support and non-slip soles.

- Breathe naturally, never holding your breath during an exercise.

- Perform exercises consistently with proper technique and pass through a full range of

motion.

- Increase resistance by adding heavier weights. Decrease resistance by using lighter

weights.

- Always use a spotter for safety.

- Avoid over-training. You should be able to carry on a conversation while exercising.

- After an exercise session. Cool down with slow stretching, cycling or walking.

EXERCISE DEFINITIONS:

Sets: A set is one complete routine of exercises. Complete 1-3 sets for each exercise.

Repetitions: (referred to as reps) Is the number of times you perform an exercise in a row.

We recommend beginning with 6 reps and increasing up to 12 reps as indicated below.

Novice: Start with one set of 8-12 reps. Once you can complete the entire set of 12 reps con-

secutively, progress to the intermediate level.

Intermediate: Complete 2 sets of 8-12 reps once you can complete two sets of 12 reps con-

secutively, progress to the advanced level.

Advanced: Complete 3 sets of 12 reps

DISCLAIMER:

Keys Fitness is not responsible for the misuse of any of its products or for any injury sustained

while using any Keys Fitness product. The consumer uses any or all of Keys Fitness products at

their own risk.

WARNING!

1) The max user weight limit for this unit is 300 pounds.

2) The max total weight limit for this unit is 600 pounds (user weight + lifting weight).

Assembly

Olympic Adapter

Leg Extension

w/ Curl Bar Weight Plate Holder

Safety Spotter

Weight Rest

Adjustable Tube

Arm Curl Pad

Thank you for purchasing the Strength Trainer International Bench! The quality product you

have chosen was designed to meet your needs for cardiovascular exercise. Before you start,

please read the Owner’s Manual and become familiar with the operation of your new unit.

Remember to take the time to perform stretching exercises, provided in this manual, to help

avoid injury.

Getting Started - The Strength Trainer International Bench will require some assembly.

Unpack the box in a clear area. Remove packing material. Do not dispose of packing mate-

rial until assembly is complete and unit is working properly. Place the unit on a clean level

surface for assembly. Before assembling, the unit should be placed as close as possible to its

final location. If you are missing any parts or hardware, please call Keys Fitness at 1-888-340-

0482. Tools have been provided to assist with product assembly. Keys Fitness recommends for

two people to assemble the unit. As you assemble the bench, make sure all parts are oriented

as shown in the drawings.

The included hex key, grease packet, and the following tools (not included) are recommended

for assembly.

Hex Key (Included)

Two Adjustable Wrenches

Rubber Mallet

Flat Head Screwdriver

Phillips Head Screwdriver

Assembly

M10 Nylon Locknut (58)

M8 Washer (50)

M8 Nylon Locknut (49)

M8 x 65mm Bolt (46)

M6 Washer (54)

M10 x 145mm Bolt (53)

M6 x 20mm

Screw (41)

M8 x 70mm Bolt (71)

M10 x 65mm Bolt (30)

M8 x 10mm

Set Screw (60)

M8 x 60mm Bolt (59)

M4 x 16mm

Screw (57)

M10 x 60mm Carriage Bolt (29)

M6 x 40mm Screw (48)

M10 x 120mm Bolt (14)

M10 x 70mm Bolt (33)

M10 x 95mm Bolt (64)

M10 Washer (43)

M10 x 70mm Bolt Set (55)

Hardware Identifier

See the drawings below to identify the hardware used in the assembly. The number in paren-

theses is the reference number of the part.

Note: Some hardware may be pre-installed in some parts.

Recessed Areas

Assembly

Step 1

Insert four M10X60mm carriage bolts (29) up through the bottom of the right stabilizer (2).

Attach the right upright (4) to the right stabilizer (2) with indicated carriage bolts and nylon

locknuts (58).

Repeat to complete the assembly of the left stabilizer (1) and left upright (3).

Note: Make sure the recessed areas around the holes on stabilizers are on the bottom.

Figure 1

NOTE: Hand tighten bolts and nylon nuts until machine is fully assembled.

Assembly

Step 2

Attach the crossbar (5) to the right upright (4) using two M10X120mm bolts (14), an upright

plate (15), and two M10 nylon locknuts (58).

Repeat to complete the assembly for the left upright (not shown).

1 4

Step 3

Attach the right rear support (7) to the right stabilizer (2) using the indicated M10X60mm car-

riage bolts (29), two washers (43), and two M10 nylon locknuts (58).

Secure the right rear support (7) to the right upright (4) using two M10X65mm bolts (30), two

M10 washers (43), and two M10 nylon locknuts (58).

Repeat to complete the assembly for the left side (not shown).

Figure 2

Figure 3

NOTE: Hand tighten bolts and nylon nuts until machine is fully assembled.

Assembly

Step 4

Attach the front leg (12) to the front stabilizer (11) with two M10X95mm bolts (64) and two

M10 nylon locknuts (58).

Step 5

Position the frame (8) so that the hexagonal holes are on the bottom. Attach the frame (8)

to the crossbar (5) using three M10X70mm bolts (33), two M10 washers (43), and three M10

nylon locknuts (58).

Hexagonal

Holes

3 3

Figure 5

Figure 4

NOTE: Hand tighten bolts and nylon nuts until machine is fully assembled.

Assembly

Step 6

Tighten the "T"-handle (45) into the seat carriage (42). Pull the "T"-handle (45) out as far as

it will go and slide the seat carriage (42) onto the frame (8).

Attach the front leg (12) to the frame (8) using two M8X60mm bolts (59), two M8X65mm bolts

(46), six M8 washers (50), and four M8 nylon locknuts (49).

Step 7

Set the pins on the adjustment tube (9) into a set of brackets located on the left and right

uprights (3 & 4).

Figure 7

Figure 6

NOTE: Hand tighten bolts and nylon nuts until machine is fully assembled.

Assembly

Step 8

Attach the tether on the seat adjustment pin (40) to the seat frame (10) using an M4X16mm

screw (57).

Attach the seat pad (21) to the seat frame (10) with four M6X20mm screws (41).

Step 9

Attach the backrest pad (22) to the two backrest frames (17) with four M6X40mm screws (48)

and four M6 washers (54).

Note: Do not fully tighten the screws yet.

Figure 9

1 0

Figure 8

NOTE: Hand tighten bolts and nylon nuts until machine is fully assembled.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Keys Fitness Fitnessgeräte Handbücher

Keys Fitness

Keys Fitness Horizontal Pressing Station KPS-2050 Bedienungsanleitung

Keys Fitness

Keys Fitness Leg Machine KF-LEGM Bedienungsanleitung

Keys Fitness

Keys Fitness KF-SPC Bedienungsanleitung

Keys Fitness

Keys Fitness Functional Trainer KF-FT Bedienungsanleitung

Keys Fitness

Keys Fitness Strength Trainer ST-LEG Bedienungsanleitung

Keys Fitness

Keys Fitness Calf Raise KF-CR Bedienungsanleitung

Keys Fitness

Keys Fitness Leg Press Attachment KPS-LP1 Bedienungsanleitung

Keys Fitness

Keys Fitness CALF RAISE KPS-CR Bedienungsanleitung

Keys Fitness

Keys Fitness Strength Trainer ST-VDB Bedienungsanleitung

Keys Fitness

Keys Fitness ST-NBB Bedienungsanleitung

Keys Fitness

Keys Fitness StrenghtTrainer ST-ARM Bedienungsanleitung

Keys Fitness

Keys Fitness Power Cage Lat Attachment KPS-PCL Bedienungsanleitung

Keys Fitness

Keys Fitness CG1HR Bedienungsanleitung

Keys Fitness

Keys Fitness NEOPRENE DUMBBELL RACK STDFR/B Bedienungsanleitung

Keys Fitness

Keys Fitness KF-ARMA Bedienungsanleitung

Keys Fitness

Keys Fitness Seated Preacher Curl KPS-SPC Bedienungsanleitung

Keys Fitness

Keys Fitness Adjustable Hyperextension KF-AH Bedienungsanleitung

Keys Fitness

Keys Fitness Power System KPS-SCC Bedienungsanleitung

Keys Fitness

Keys Fitness ST-FIDL Bedienungsanleitung

Keys Fitness

Keys Fitness ROMAN CHAIR KPS-RC Betriebsanleitung

Keys Fitness

Keys Fitness Leg Attachment KPS-LEGA Bedienungsanleitung

Keys Fitness

Keys Fitness StrenghtTrainer ST-OBA2 Bedienungsanleitung

Keys Fitness

Keys Fitness Half Cage PeC Attachment KF-HCP Bedienungsanleitung

Keys Fitness

Keys Fitness Leverage Squat KPS-LS Bedienungsanleitung

Beliebte Fitnessgeräte Handbücher anderer Marken

NSD

NSD PB-188P Bedienungsanleitung

Performance

Performance HyperVibe Bedienungsanleitung

Scalamobil

Scalamobil S27 Bedienungsanleitung

Precor

Precor Experience Series Bedienungsanleitung

FYTTER

FYTTER RedMIUM BENCH BE-T6R Bedienungsanleitung

Taurus

Taurus TF-RK1312 Bedienungsanleitung

Nustep

Nustep T5 Bedienungsanleitung

Precor

Precor CW-507 Bedienungsanleitung

Movement

Movement BICEPS Idea Bedienungsanleitung

Kegel8

Kegel8 V For Men Bedienungsanleitung

BLK BOX

BLK BOX 21-0122-0B Bedienungsanleitung

Stamina

Stamina aeropilates premier 299 Bedienungsanleitung

SPORTSTECH

SPORTSTECH PBX300 Bedienungsanleitung

ParaBody

ParaBody Serious Steel 877102 Bedienungsanleitung

Weslo

Weslo Gym 650 Bedienungsanleitung

Rebel

Rebel ACTIVE RBA-1011 Bedienungsanleitung

4iiii

4iiii FLiiiight Bedienungsanleitung

Image

Image 540 Bedienungsanleitung