Keys Fitness TRI-ENDURANCE Treadmill TRI-ENDURANCE Bedienungsanleitung

Owner’s Manual

Model Name : TRI-ENDURANCE

Serial Number :

Write down for future reference

Serial Number Decal Location

415-00064

09/06 Rev A

CAUTION! Read all precautions

and instructions in this manual

before using this equipment.

Triumph Endurance Treadmill

Customer Service

(888) 340-0482

Keys Fitness Products

4009 Distribution Drive

Suite 250

Garland, TX 75041

www.keysfitness.com

Table of Contents

Important Safety Information 3

Before You Start 4

Assembly 5-9

Moving Instructions 10

Power Requirements 11

Console Panel Functions 12

Program Operation 13-14

Program Profiles 15

Monitoring Your Heart Rate 16-17

Warm Up Exercises 18

Changing to MPH or KM 19

Calibration Sequence 20

Belt Adjustment 21

Maintenance Instructions 22

Error Messages 23

Troubleshooting 24

Parts List 25

Exploded View 26-27

Warranty Information 28

Important Safety Information

WARNING! Before using this treadmill or starting any exercise program, consult your

physician. This is especially important for persons over the age of 35 and/or persons with

pre-existing health problems. The manufacturer or distributor assumes no responsibility for

personal injury or property damage sustained by or through the use of this product.

WARNING! To reduce the risk of electrical shock, burns, fire, or other possible injuries to the

user, it is important to review this manual and the following precautions before operation.

SAVE THESE INSTRUCTIONS

SAFETY PRECAUTIONS AND TIPS

1. Always secure Safety Key firmly to waistband.

2. It is the owner’s responsibility to ensure that all users of this treadmill have read the

Owner’s Manual and are familiar with warnings and safety precautions.

3. This treadmill has a user maximum capacity of 300 pounds.

4. The treadmill should only be used on a level surface and is intended for indoor use only.

The treadmill should not be placed in a garage, patio, or near water and should never be used

while you are wet. Keys recommends a treadmill mat be placed under the treadmill to protect

floor or carpet and for easier cleaning.

5. Follow safety information in regard to plugging in your treadmill. Keep the power cord away

from the incline wheels and do not run the power cord underneath your treadmill. Do not

operate the treadmill with a damaged or frayed power cord.

6. Wear comfortable, good-quality walking or running shoes and appropriate clothing. Do not

use the treadmill with bare feet, sandals, socks or stockings.

7. Always straddle the belt and allow it to start moving before stepping onto the belt.

8. Hold on to handrail when adjusting speed or other controls.

9. Always examine your treadmill before using to ensure all parts are in working order.

10. Allow the belt to fully stop before dismounting.

11. Pets should never be allowed near or on the treadmill.

12. Close supervision is necessary when this appliance is used by or near children, invalids or

disabled persons.

13. Never operate the treadmill where oxygen is being administered, or where aerosol products

are being used.

14. Never insert any object or body parts into any opening.

15. For safety and to prevent damage to your treadmill, no more than one person should use

the treadmill at a time.

16. Always unplug the treadmill before cleaning and/or servicing. Service to your treadmill

should only be performed by an authorized service representative, unless authorized and/or

instructed by the manufacturer

17. Failure to follow these instructions will void the treadmill warranty.

18. Never leave the treadmill unattended when plugged in. Unplug from outlet when not in

use and before service or maintenance.

19. Always unplug this appliance immediately after using and before cleaning. To disconnect,

turn all controls to the off position, then remove plug from outlet.

Before You Start

Thank you for purchasing the Triumph Endurance Treadmill! This quality product you have

chosen was designed to meet your needs for cardiovascular exercise. Before you start, please

read the Owner's Manual and become familiar with the operation of your new treadmill.

Remember to take the time to perform the stretching exercises provided to avoid

injury.

Do not stand on the walking belt while pressing the Power button or Start/Stop button.

Always adjust the speed of the treadmill in small increments as this treadmill is capable of

high speeds.

If you are taking medication, consult your physician to see if the medication will affect your

exercise heart rate.

If you have heart problems, you are not active, and/or are over the age of 35 years, do not

use the pre-set treadmill programs or start an exercise program without first contacting and

receiving approval from your physician.

To avoid the risk of electrical shock, always keep the console dry. Do not spill liquids on the

console. Keys Fitness recommends a sealed water bottle for beverages consumed while using

the treadmill.

Please review the following drawing below to familiarize yourself with the listed

parts. This manual covers several treadmills, so the one pictured below may not be

identical to your particular model.

CONSOLE

LATCH

MOTOR COVER

LEFT UPRIGHT

RIGHT UPRIGHT

TRANSPORT WHEEL

RUNNING BELT

Assembly

The Triumph Endurance Treadmill will require assembly before operating. After opening the

box, remove any packing material from the treadmill.

Do not throw away any packing materials until the unit is working properly.

Place the base on a clean, level surface. Make sure the electrical cord will easily reach an elec-

trical outlet.

Locate the hardware pack and identify the following parts required for assembly.

Parts List:

1. Owner’s Manual

2. Base Assembly

3. Console Assembly

4. Left and Right Upright

5. Left and Right Fender

6. Safety Key (Reed Switch)

7. Left and Right Inside Handle Covers

8. Left and Right Outside Handle Covers

9. Allen Wrench

10. Phillips Screw M6x12 (Qty. 6)

11. Phillips Screw ST4.2x13 (Qty. 8)

12. Allen Bolt M8x15 (Qty. 8)

13. Washer 9x22x2 mm (Qty. 8)

Assembly

Assembly requires the included allen

wrench.

Do not plug in the power cord until all

assembly steps are completed.

Step 1:

Place the left and right fenders through

the tube of the left and right uprights as

shown in Figure 1.

Figure 1

Figure 2

Step 2:

Slide the fenders up the upright assembly

and pull the console harness through the

hole in bottom of the left upright tube as

shown in Figure 2.

CONSOLE HARNESS

FENDERS

UPRIGHTS

Assembly

Figure 3

Figure 4

Step 3:

Connect the console harness from inside

the left upright to the console harness from

the base assembly as shown in Figure 3.

Next, attach left upright and right upright

to base using Allen bolts M8x15 (Qty. 8)

and washers 9x22x2 mm (Qty. 8). Do not

tighten bolts all the way at this time.

Step 4:

Attach the console assembly by connect-

ing the console harness, incline harness,

EKG harness, and speed harness as shown

in Figure 4.

Next, attach the console assembly to the

left and right uprights using Phillips screws

M6x12 (Qty. 4).

CONSOLE HARNESS

ALLEN BOLT

WASHER

PHILLIPS SCREW

CONSOLE

WIRE HARNESS

UPRIGHTS

Assembly

Step 5:

Attach left inside handle cover and left

outside handle cover to left upright using

Phillips screw ST4.2x13 (Qty. 3) as shown in

Figure 5.

Repeat assembly step for right side handle

covers.

Figure 5

Figure 6

Step 6:

Tighten all Allen bolts (Qty. 8) installed

in Step 3. Note: Move the fenders up to

access the Allen bolts.

Next, attach both left and right fend-

ers to base using Phillips screws ST4.2x13

(Qty. 2) and Phillips screws M6x12

(Qty. 2).

Move the treadmill to its final location

(see section titled “Moving Instructions”).

Adjust the leveler feet so that the treadmill

does not wobble while in use.

PHILLIPS SCREW

FENDER LEVELER

FOOT

Assembly

Congratulations!

You have completed the assembly of your new Triumph Endurance

Treadmill.

Moving Instructions

Caution! To avoid the risk of injury, never attempt to move the treadmill while it is in

the unfolded operating position. To reduce the possibility of injury while lifting, bend

your legs and keep your back straight. As you raise the treadmill, lift using your legs,

not your back. In order to raise or lower the treadmill safely, you must be able to lift

45 pounds (20kg). It is suggested you always use the aid of a second person when

moving the treadmill.

With the treadmill in the folded locked position (safety latch is engaged), grasp the handrail

and place one foot on the center of the base crossbar as shown in the photo below. Next, with

a firm grasp on the handrail, carefully tilt the treadmill back until it rolls freely on the wheels.

Using extreme caution, move the treadmill to the desired location. To set the treadmill down,

place one foot on the center of the base crossbar and carefully lower treadmill onto base in

resting position. Do not attempt to move the treadmill over an uneven or rough surface.

Note: The treadmill pictured below may not be identical to your particular model.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Keys Fitness Tretmühle Handbücher

Keys Fitness

Keys Fitness HealthTrainer HT601 Bedienungsanleitung

Keys Fitness

Keys Fitness Alliance A4t Bedienungsanleitung

Keys Fitness

Keys Fitness 4600T Bedienungsanleitung

Keys Fitness

Keys Fitness HT95 Bedienungsanleitung

Keys Fitness

Keys Fitness CardioZone CZE Bedienungsanleitung

Keys Fitness

Keys Fitness CZE Plus Bedienungsanleitung

Keys Fitness

Keys Fitness HT2-0 Bedienungsanleitung

Keys Fitness

Keys Fitness 8500 Bedienungsanleitung

Keys Fitness

Keys Fitness CZCLUBMAX Bedienungsanleitung

Keys Fitness

Keys Fitness Health Trainer 801 Treadmill HT801 Bedienungsanleitung

Keys Fitness

Keys Fitness ENCORE 1350 Bedienungsanleitung

Keys Fitness

Keys Fitness Alliance 900 Bedienungsanleitung

Keys Fitness

Keys Fitness 8800 Bedienungsanleitung

Keys Fitness

Keys Fitness Treadmill CZCLUB Bedienungsanleitung

Keys Fitness

Keys Fitness PRO 400 Bedienungsanleitung

Keys Fitness

Keys Fitness Treadmill KEYS800 Bedienungsanleitung

Keys Fitness

Keys Fitness DCV560HR Bedienungsanleitung

Keys Fitness

Keys Fitness MS1200GT Bedienungsanleitung

Keys Fitness

Keys Fitness HealthTrainer HT65T.1 Bedienungsanleitung

Keys Fitness

Keys Fitness HT402t Bedienungsanleitung

Keys Fitness

Keys Fitness EC1500-C Bedienungsanleitung

Keys Fitness

Keys Fitness 980HRS Bedienungsanleitung

Keys Fitness

Keys Fitness Alliance A5t Bedienungsanleitung

Keys Fitness

Keys Fitness 6600t Bedienungsanleitung

Beliebte Tretmühle Handbücher anderer Marken

Treadly

Treadly TREADLY 2 Bedienungsanleitung

HEALTH ONE

HEALTH ONE Walk Ro Bedienungsanleitung

NordicTrack

NordicTrack T7.5 S Bedienungsanleitung

Gold's Gym

Gold's Gym ADVANTAGE GGTL12920 Bedienungsanleitung

Merax

Merax MS282992 Bedienungsanleitung

FYTTER

FYTTER RU-2SX Bedienungsanleitung

Precor

Precor 903 Bedienungsanleitung

FitLogic

FitLogic freewill d225 Bedienungsanleitung

HOP-SPORT

HOP-SPORT ESTIMA HS-3200LB Bedienungsanleitung

Horizon Fitness

Horizon Fitness Adventure 5 Plus Bedienungsanleitung

Stamia

Stamia InMotion II Bedienungsanleitung

Smooth Fitness

Smooth Fitness EVO 3i Bedienungsanleitung

NordicTrack

NordicTrack NETL81810.0 Bedienungsanleitung

Schwinn

Schwinn 830/Journey 8.0 Bedienungsanleitung

Spirit

Spirit XT8 Bedienungsanleitung

NordicTrack

NordicTrack T 14.0 Treadmill Bedienungsanleitung

Master

Master F22 Bedienungsanleitung

Precor

Precor PRECISION SERIES Technisches Handbuch