Mercia Garden Products 01PTPOT0806-V1 Gebrauchsanweisung

ANTI-ROT

GUARANTEE TODAY

PLEASE SCAN HERE:

Measure

under the

head

Measure

overall

length

Screws & Nails Bolts To identify the

xings required

for each step use a

measuring tape.

01PTPOT0806-V1

8x6 Pressure Treated Pottng Shed

2mm Drill bit

x2 Winter = High Moisture = Expansion

Summer = Low Moisture = Contraction

All buildings should be

erected by two adults

For ease of assembly, you

MUST pilot drill all screw

holes and ensure all screw

heads are countersunk.

For assistance please contact customer care on: 01636 821215

Mercia Garden Products Limited,

Sutton On Trent,

Newark,

Nottinghamshire,

NG23 6QN

www.merciagardenproducts.co.uk

CAUTION

Every eort has been made during the

manufacturing process to eliminate the

prospect of splinters on rough surfaces of the

timber. You are strongly advised to wear gloves

when working with or handling rough sawn

timber.

BEFORE YOU START PLEASE READ INSTRUCTIONS CAREFULLY

- Check the pack and make sure you have all the parts listed.

- When you are ready to start, make sure you have the right tools at hand (not supplied) including a Phillips screw-

driver, Stanley knife, Wood saw, Step ladder, Hammer and a Drill with 2mm bit.

- Ensure there is plenty of space and a clean dry area for assembly.

TIMBER

As with all natural materials, timber can be aected during various weather conditions. For the duration of heavy

or extended periods of rain, swelling of the wood panels may occur. Warping of the wood may also occur during

excessive dry spells due to an interior moisture loss. Unfortunately, these processes cannot be avoided but can be

helped. It is suggested that the outdoor building is sprayed with water during extended periods of warm sunshine

and sheltered as much as possible during rain or snow.

Once your garden building has been installed it will need to be treated as soon as possible and annually to prevent

the timber from deteriorating and to waterproof it. This is required to maintain the anti-rot guarantee.

Dip Treated buildings - Require a preservative treatment to protect against rot and decay and a waterproof treat-

ment to prevent water ingress

Pressure Treated buildings - Require a waterproof treatment to prevent water ingress

Log Cabins - Are supplied untreated and require a preservative and waterproong treatment.

BUILDING A BASE

When thinking about where the building and base is going to be constructed:

Ensure that there will be access to all sides for maintenance work and annual

treatment.

Ensure the base is level and is built on rm ground, to prevent distortion. Refer to diagrams for the base

dimensions, The base should be slightly smaller than the external measurement of the building, i.e. The cladding

should overlap the base, creating a run o for water. It is also recommended that the oor be at least 25mm above

the surrounding ground level to avoid ooding.

TYPES OF BASE

- Concrete 75mm laid on top of 75mm hard-core.

- Slabs laid on 50mm of sharp sand.

Whilst all products manufactured are made to the highest standards of Safety and in the case of childrens

products independently tested to EN71 level, we cannot accept responsibility for your safety whilst erecting or

using this product.

Refer to the instructions pages for your specic product code

For ease of assembly, you

will need a tape measure to

check dimensions of

components.

Pressure Treated Timber

Pressure treating is a chemical process which helps to protect wood against adverse weather which could

lead to rot or insect damage.

The most common chemicals used to pressure treat wood are Alkaline Copper Quaternary (ACQ),

Copper Azole (CA), and Micronized Copper Quaternary (MCQ).

Safety: Always wear gloves, eye protection and a dust mask when handling wood. Due to chemicals in

pressure treated wood, never burn its sawdust or scraps; instead dispose in a landll.

P 1

Please retain product label and instructions for future reference

General Instructions

P 2

01PTPOT0806-V1

Overall Dimensions:

Width = 2515 mm

Depth = 1900 mm

Height = 2141 mm

Base Dimensions:

Width = 2476 mm

Depth = 1863 mm

Please retain product label and instructions for future reference

Before assembly

please make sure you have a

suitable base ready to erect your

building

MADE IN GREAT BRITAIN

Door Panel QTY 1

AI-01POT0806DG-V1

1234 5

8 9

10 11 12 13

Plain Panel QTY 3

AI-01POT0806PG-V1

Floor Panel QTY 1

AI-01POT0806F-V1

Side Panel QTY 1

AI-01POT0806SP-V1

Side Gable Left QTY 1

AI-01POT0806SGL-V1

Glazed Roof QTY 1

AI-01POT0806GR-V1

Roof Panel QTY 2

AI-01POT0806R-V1

Bench QTY 1

AI-01POT0806B-V1

Gable Top Right QTY 1

AI-01POT0806GTR-V1

Opening Window QTY 1

AI-01POT0806OW-V1

Door QTY 1

AI-01POT0806D-V1

Side Panel Trim - 12X45X1004mm QTY 2 - S1245-1004MM

Glazed Roof Fascia - 12X88X1272mm QTY 2 - S1288-G-1272MM

Bench Support Frame - 27X44X958mm QTY 1 - F2744-958MM

Angled cut cover trim - 12X45X2046mm QTY 2 - S1245-G-2046MM

Panel Cover Trim - 12X55X1793mm QTY 3 - S1255-1793MM

Roof Strip- 12X50X1273mm QTY 2 - S1250-1273MM

Fascia - 12X70X1340mm QTY 2 - S1270-1340MM

Fascia - 12X70X1273mm QTY 2 - S1270-1273MM

Bench Support Frame - 44X44X657mm QTY 2 - F4444-657MM

Bench Support Block - 44X44X120mm QTY 1 - F4444-120MM

Window Frame - 35X41X650mm QTY 1 - F3541-G-650MM

Side Gable Right QTY 1

AI-01POT0806SGR-V1

Gable Top Left QTY 1

AI-01POT0806GTL-V1

Building Content:

Turn button QTY 2

PI-07-0034

Felt

Casement Stay QTY 1

PI-07-0080

Pad bolt QTY 1

PI-07-0035

2925

Small Hinge QTY 2

PI-07-0004

T Hinge QTY 3

PI-07-0021

Nail Bag

There may be extra screws present in the nail bag

30mm Screw x 65

50mm Screw x 60

70mm Screw x 12

40mm Screw x 31

Felt Tacks x 60

16mm Black Screw x 22

P 3

Please retain product label and instructions for future reference

Pre Assembly

Before assembling remove the transportation

blocks from the bottom of each panel.

Take care removing the blocks as to not damage

the panels. Tap with a at headed screwdriver

and hammer.

Dispose of the blocks once removed.

21 x 30mm screws

Fix the T Hinges onto the

doors and door frame as

shown. Ensure that the

screws go through the

cladding and into the

framing behind.

Pre Assembly

Step 1

Place oor on a rm and level base, ensure

base has suitable drainage free from areas

where standing water can collect.

(See front page on base requirements).

The door and plain panels are

interchangeable and can be

positioned in a variety of

congurations, Decide which works

best before assembly .

(see end of step 3)

Fix the corner with 3x 50mm screw a

shown in diagram.

Do not secure the building to the oor

until the roof is tted. Fix the panels

onto the oor using 50mm screws in

alignment with the oor joists.

7 x 50mm screws

Step 2

50mm

screw

Pre drill

hole

P 4

For assistance please contact customer care on: 01636 821215

Mercia Garden Products Limited,

Sutton On Trent,

Newark,

Nottinghamshire,

NG23 6QN

www.merciagardenproducts.co.uk

BEFORE YOU START PLEASE READ INSTRUCTIONS CAREFULLY

- Check the pack and make sure you have all the parts listed.

- When you are ready to start, make sure you have the right tools at hand (not supplied) including a Phillips screw-

driver, Stanley knife, Wood saw, Step ladder, Hammer and a Drill with 2mm bit.

- Ensure there is plenty of space and a clean dry area for assembly.

TIMBER

As with all natural materials, timber can be aected during various weather conditions. For the duration of heavy

or extended periods of rain, swelling of the wood panels may occur. Warping of the wood may also occur during

excessive dry spells due to an interior moisture loss. Unfortunately, these processes cannot be avoided but can be

helped. It is suggested that the outdoor building is sprayed with water during extended periods of warm sunshine

and sheltered as much as possible during rain or snow.

Once your garden building has been installed it will need to be treated as soon as possible and annually to prevent

the timber from deteriorating and to waterproof it. This is required to maintain the anti-rot guarantee.

Dip Treated buildings - Require a preservative treatment to protect against rot and decay and a waterproof treat-

ment to prevent water ingress

Pressure Treated buildings - Require a waterproof treatment to prevent water ingress

Log Cabins - Are supplied untreated and require a preservative and waterproong treatment.

BUILDING A BASE

When thinking about where the building and base is going to be constructed:

Ensure that there will be access to all sides for maintenance work and annual

treatment.

Ensure the base is level and is built on rm ground, to prevent distortion. Refer to diagrams for the base

dimensions, The base should be slightly smaller than the external measurement of the building, i.e. The cladding

should overlap the base, creating a run o for water. It is also recommended that the oor be at least 25mm above

the surrounding ground level to avoid ooding.

TYPES OF BASE

- Concrete 75mm laid on top of 75mm hard-core.

- Slabs laid on 50mm of sharp sand.

Whilst all products manufactured are made to the highest standards of Safety and in the case of childrens

products independently tested to EN71 level, we cannot accept responsibility for your safety whilst erecting or

using this product.

Refer to the instructions pages for your specic product code

Please retain product label and instructions for future reference

Pre drill

hole

Step 3

Fix the second set of panels

using same method shown in

step 2.

10 x 50mm screws

50mm

screw

Step 4

Fix the side gables using same

method shown in step 2.

50mm

screw

10 x 50mm screws

Pre drill

hole

Step 5

Fix side panel using step 2 method.

Place the gable tops into position

as shown in diagram and x using

50mm screws

15 x 50mm screws

50mm

screw

Pre drill

hole

16 x 16mm black screws

3 x 70mm screws

Step 6

Place the opening window and

window frame on top of the glazed roof

panel. Ensure there is a 12mm gap

between the window frame and top

end of the glazed roof panel. Fix the

window block with 70mm screws.

Place the small hinges as in diagram

and x with 16mm black screws.

12mm

16mm

black

screw

70mm

screw

Pre drill

hole

P 5

Please retain product label and instructions for future reference

Position glazed roof panel on

top of side gable and up against

the gable top. Secure to gable

top with 40mm screws and to

the gable sides using 70mm

screws as shown.

4 x 40mm screws

9 x 70mm screws

40mm

screw 70mm

screw

Step 7

Pre drill

hole

Step 8

Fix roof strip to back of each

panel against end as shown

using 30mm screws.

8 x 30mm screws

30mm

screw

Pre drill

hole

Place the roof panels on

top ensuring the underside

strip roof is at the top side

of the building. Fix roof

using 50mm screws.

Step 9

8 x 50mm screws

50mm

screw

Pre drill

hole

P 6

Please retain product label and instructions for future reference

Step 10

Cut felt into two sheets ensuring

they are both long enough to

cover roof with 50mm overhang

around the sides. Overlap where

the two sheets meet and x onto

roof using felt tacks at 10cm

intervals.

Felt

tacks

Step 11

Fix fascias using 40mm screws. Pre

drill holes to avoid splitting. Ensure

to the trap the felt between the

fascia and building.

24 x 40mm screws

40mm

screw

Pre drill

hole

14 x 30mm screws

Step 12

Fix Cover trims using 30mm

screws as shown. Pre drill holes

to avoid splitting.

30mm

screw

Pre drill

hole

Step 13

Fix Cover trims using

30mm screws as shown.

Pre drill holes to avoid

splitting.

12 x 30mm screws

30mm

screw

Pre drill

hole

P 7

Please retain product label and instructions for future reference

Step 14

Fix casement stay to glazed roof using 16mm

black screws. Attach bench support frame to

either gable side using 50mm screws. Ensure

screws go into framing , pre-drill holes to

avoid splitting.

50mm

screw

16mm

black

screw

4 x 50mm screws

4 x 16mm black screws

Pre drill

hole

Step 15

Place the remaining bench support on the inside of the

bench at the centre and x against bench framing using

40mm screw.

Then at the bottom attach support block to frame and to

the oor using 40mm screws.

Finish securing the bench by screwing 2x 50mm

screws through the benches framing into the framing of

the side panel

Place Bench on top of supports and x in place using

50mm screws from the bottom up through the supports

and into the bench framing. Pre drill rst.

40mm

screw

6 x 50mm screws

3 x 40mm screws

50mm

screw

Pre drill

hole

Please retain product label and instructions for future reference

P 8

Step 16

Fix Padbolt using 30mm screws. Then x

turn buttons to top and bottom of the

door using 16mm black screw

16mm

black

screw

30mm

screw

10 x 30mm screws

2 x 16mm black screws

Pre drill

hole

It is ESSENTIAL that you apply wood

treatment immediately after the building

has been assembled.

AFTER TREATMENT:

score around protective

cover on glazing and

carefuly peel

covering back

P 9











































































































































4



















P 7

ANTI-ROT

GUARANTEE TODAY

PLEASE SCAN HERE:







































¡











2





































Inhaltsverzeichnis

Andere Mercia Garden Products Gartenhaus Handbücher

Mercia Garden Products

Mercia Garden Products POPPY PLAYHOUSE Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 03HEL1008DDFW-V3 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01DTOVRA0806SDFW-V2 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 02PLAY511511-V2-PEFC Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01DTSHAX0806SDSEC-V2 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 0644LOG208-V3 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01DTSHAX0406SDFW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 10DTSHPN0804-V1 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 01OVLPP0705SDFW-V1 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 01GRO0806DD-V2 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 0619PNNE2424HGDD1SW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 03DTSHCR0808FGD2TW-V2 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 01GRODB1008-V3 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01SHPWOR1010DDOW-V2 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 03TGCOR0707-V5 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 06LOG173SG-V1 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 06LOG002-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 03LBRO1208-V7 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 02CHY0404-V3 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 01PTOSBRA0604SDFW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 0634RANE4535FGDD2TW1SW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01OVLPA0808DDFW-V1 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products GROUNDSMAN 10 X 8 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 03HEL1008DDFW-V2 Bedienungsanleitung

Beliebte Gartenhaus Handbücher anderer Marken

Lemeks

Lemeks Palmako PA120-5930-6 Installationshandbuch

Rion

Rion Hobby Gardener Bedienungsanleitung

Gartenhaus-King

Gartenhaus-King Valery Bedienungsanleitung

Select

Select ISAAC E9682 Bedienungsanleitung

Palmako

Palmako Saale Bedienungsanleitung

Lemeks

Lemeks Palmako Kira EL16-3623 Installationshandbuch

Palmako

Palmako Roger FR44-5953-2 Bedienungsanleitung

Pergola kits USA

Pergola kits USA PREMIUM VINYL PAVILION Bedienungsanleitung

G21

G21 Boston 882 Bedienungsanleitung

Lemeks

Lemeks Palmako Grace PM56-4529 Installationshandbuch

Shire

Shire Salcey Bedienungsanleitung

Rutland County

Rutland County Burley 6ft Bedienungsanleitung

Palmako

Palmako Roger 27,7 Bedienungsanleitung

Lemeks

Lemeks Palmako PA120-5930-9 Installationshandbuch

Lemeks

Lemeks Palmako PM70-6436 Installationshandbuch

Lemeks

Lemeks Palmako PM56-4435 Installationshandbuch

Lemeks

Lemeks 106214 Installationshandbuch

POD

POD Camping 480 Bedienungsanleitung