Moxa Technologies CA-132 series Bedienungsanleitung

CA-132/132I

Quick Installation Guide

www.moxa.com/product

Second Edition, November 2004

Moxa Technologies Co., Ltd.

Tel: +886-2-8919-1230

Fax: +886-2-8919-1231

Web: www.moxa.com

MOXA Technical Support

Worldwide: support@moxa.com.tw

The Americas: support@moxa.com

CA-132/132I

Quick Installation Guide

The software described in this manual is furnished under a license

agreement and may be used only in accordance with the terms of

that agreement.

Reproduction without permission is prohibited.

Trademarks

MOXA is a registered trademark of The Moxa Group.

All other trademarks or registered marks in this manual belong to

their respective manufacturers.

Disclaimer

Information in this document is subject to change without notice

and does not represent a commitment on the part of Moxa.

Moxa provides this document “as is,” without warranty of any

kind, either expressed or implied, including, but not limited to, its

particular purpose. Moxa reserves the right to make improvements

and/or changes to this manual, or to the products and/or the

programs described in this manual, at any time.

Information provided in this manual is intended to be accurate and

reliable. However, Moxa Technologies assumes no responsibility

for its use, or for any infringements on the rights of third parties

that may result from its use.

This product might include unintentional technical or

typographical errors. Changes are periodically made to the

information herein to correct such errors, and these changes are

incorporated into new editions of the publication.

Table of Contents

Chapter 1 Introduction………………………… 1-1

Overview............................................................. 1-2

Package Checklist .............................................. 1-2

Product Features ................................................ 1-2

Product Specifications ........................................ 1-3

Chapter 2 Hardware Installation…………….. 2-1

Block Diagram of CA-132/132I ........................... 2-2

RS-422/485 Interface Settings............................ 2-3

I/O Base Address & Interrupt Vector Settings .... 2-4

IRQ Setting ......................................................... 2-7

Initial Inspection.................................................. 2-7

RS-422/485 Pin Assignments............................. 2-7

Chapter 1 Introduction

Welcome to MOXA CA-132/132I Series of advanced 2-port

RS-422/485 PC/104 communication modules, a new industrial

multiport serial board solution. Both ports of CA-132/132I can be

configured by DIP Switch for either the RS-422 or RS-485

interface, and with its PC/104 standard, the CA-132/132I Series is

compatible with any PC/104 CPU module or CPU card that

accepts PC/104 expansion modules.

The following topics are covered in this chapter:

!Overview

!Package Checklist

!Product Features

!Product Specifications

1-2

Overview

CA-132/132I is a PC/104 module that supports the RS-422/485

serial interfaces, and can be used with PC/104 CPU modules or

CPU cards that accept PC/104 expansion modules. CA-132/132I

has two independent serial interfaces, which are accessed through

RJ45 connectors. You can configure both ports for the RS-422 or

RS-485 interfaces by DIP switch. The module’s industry-standard

MOXA UART (16C550 compatible) is fully programmable. Moxa

has implemented its patented ADDC™ technology for RS-485

automatic direction control, so there is no need to change jumpers

to switch the module between driver and receiver. The built-in 16

KV ESD surge protection protects other devices connected to the

RS-485 network.

Package Checklist

MOXA CA-132/132I products are shipped with the following

items:

!1 MOXA CA-132/132I 2-port serial board

!CA-132/132I Document & Software CD

!CA-132/132I Quick Installation Guide

NOTE: Notify your sales representative if any of the above items is

missing or damaged.

Product Features

CA-132/132I Series products enjoy the following features:

!2 RS-422/485 ports

!RS-422/485 communication distance up to 4000 feet (1.2 km)

!High speed data transmission rate up to 230.4 Kbps

Introduction

1-3

!Switch selectable for I/O and INT Vector addresses

(from Hex 000 to 3FF)

!64-byte FIFOs

!IRQ settings are selectable by jumper

!Built-in 16 KV ESD surge protection for TX and RX lines

!4 LED indicators onboard (red for TX, and green for RX)

!Support 4-wire RS-422 and 2/4-wire RS-485

!ADDC™ for RS-485 transmission

!CA-132I has 2 KV isolation protection

Product Specifications

CA-132/132I Series boards have the following specifications:

!Dimensions: 9.6 cm ×9.0 cm

!Bus: PC/104

!Baud rate: 50 to 230.4 Kbps

!Character length: 5, 6, 7, or 8 bits

!Parity: even, odd, none, mark, and space

!Stop bit: 1, 1.5 or 2

!I/O connectors: dual 8-pin RJ-45 connectors

!Interrupt levels: IRQ 3, 4, 5, 6, 7, 9, 10, 11, 12 or 15

!Clock input: 14.745 MHz

!Power consumption (+5 V): CA-132/190 mA, CA-132I/405 mA

!MTBF: 100,000 hrs @ 25°C environment

!Operating temperature: 0 to 55°C

!Storage temperature: -20 to 85°C

!Relative humidity: 5 to 95%, non-condensing

Chapter 2 Hardware Installation

This chapter includes information about hardware installation of

CA-132/132I Series boards.

The following topics are covered:

!Block Diagram of CA-132/132I

!RS-422/485 Interface Settings

!I/O Address & Interrupt Vector Settings

!IRQ Setting

!Initial Inspection

!RS-422/485 pin assignments

2-2

Block Diagram of CA-132/132I

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Moxa Technologies Steuereinheit Handbücher

Moxa Technologies

Moxa Technologies MiiNePort W1 Series Bedienungsanleitung

Moxa Technologies

Moxa Technologies WAPN005 Bedienungsanleitung

Moxa Technologies

Moxa Technologies CA Series Bedienungsanleitung

Moxa Technologies

Moxa Technologies MiiNePort W1 Series Bedienungsanleitung

Moxa Technologies

Moxa Technologies MiiNePort E Series Bedienungsanleitung

Moxa Technologies

Moxa Technologies MiiNePort W1 Series Bedienungsanleitung

Moxa Technologies

Moxa Technologies MiiNePort W1 Series Bedienungsanleitung

Moxa Technologies

Moxa Technologies WAPA003 Bedienungsanleitung

Moxa Technologies

Moxa Technologies MiiNePort E1 Series Bedienungsanleitung

Moxa Technologies

Moxa Technologies ioThinx 4500 45ML-5401 Bedienungsanleitung

Moxa Technologies

Moxa Technologies ABC-01 Bedienungsanleitung

Moxa Technologies

Moxa Technologies V2400 Series Bedienungsanleitung

Moxa Technologies

Moxa Technologies EOM-104 Series Bedienungsanleitung

Moxa Technologies

Moxa Technologies WAPN001 Bedienungsanleitung

Moxa Technologies

Moxa Technologies PWR-190-AC/DC Bedienungsanleitung

Moxa Technologies

Moxa Technologies WAPN008 Bedienungsanleitung

Moxa Technologies

Moxa Technologies CA Series Bedienungsanleitung

Moxa Technologies

Moxa Technologies EOM-G103-PHR-PTP Series Bedienungsanleitung

Moxa Technologies

Moxa Technologies DA-IRIGB-4DIO-PCI104-EMC4 Bedienungsanleitung

Moxa Technologies

Moxa Technologies NPort Z2150 Bedienungsanleitung

Moxa Technologies

Moxa Technologies WFS001 Bedienungsanleitung

Moxa Technologies

Moxa Technologies CA-134I Bedienungsanleitung

Moxa Technologies

Moxa Technologies NE-4100 Series Bedienungsanleitung

Moxa Technologies

Moxa Technologies Industio CI-134 Series Bedienungsanleitung

Beliebte Steuereinheit Handbücher anderer Marken

Festo

Festo Compact Performance CP-FB6-E Stücklistenhandbuch

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Bedienungsanleitung

JS Automation

JS Automation MPC3034A Bedienungsanleitung

JAUDT

JAUDT SW GII 6406 Series Kurzanleitung

Spektrum

Spektrum Air Module System Bedienungsanleitung

BOC Edwards

BOC Edwards Q Series Bedienungsanleitung

KHADAS

KHADAS BT Magic Bedienungsanleitung

Etherma

Etherma eNEXHO-IL Bedienungsanleitung

PMFoundations

PMFoundations Attenuverter Bedienungsanleitung

GEA

GEA VARIVENT Bedienungsanleitung

Walther Systemtechnik

Walther Systemtechnik VMS-05 Bedienungsanleitung

Altronix

Altronix LINQ8PD Montageanleitung

Eaton

Eaton Powerware Series Bedienungsanleitung

WAGO

WAGO 750-407/040-000 Bedienungsanleitung

Sony

Sony CCU-590 Bedienungsanleitung

Graco

Graco 25D614 Bedienungsanleitung

Task Force Tips

Task Force Tips YE-RF-900 Programmierhandbuch

Shini

Shini SPV-U Series Bedienungsanleitung