Town & Country Fireplaces TC30.NG05D Bedienungsanleitung

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

These instructions are supplementary to the Installation and

Operating Instructions supplied with the replace and should be kept

together.Refer to the Installation and Operating Instructions for proper

gas supply, safety requirements and operating instructions

270315-16 TC30_NG05D 5056.42905D

TC30

HEARTWOOD

BURNER INSTALLATION

INSTRUCTIONS

PART# TC30.NG05D

FOR TC30 Series D

Fireplaces

Contents of Package

5056.42905D

TC30_ng05D 270315-16

 • BURNERASSEMBLY

(including pilot and manifold)

 • LOGGRATE 

 • TC30HEARTWOODLOGS

 • EMBERMATERIAL

 • HARDWAREPACKAGE

 • AIRDEFLECTOR

 • COALCHUNKS

 • VERMICULITE

If this replace is to be

used on Propane please

convert prior to installtion.

See pages 10 – 12.

Burner Installation

1. Place the keyhole slots in the burner

over the two screws located in the rebox

base.(Fig.#1&1a)

2. Slide the burner back to engage the

screws in the small part of the keyhole

slotandtightenscrews.(Fig.#1b)

3. Remove access cover from side of

rebox(Fig.#1c)

Fig. # 1a

Fig. # 1b

SCREWS

Fig. # 1

Fig. # 1c

5056.42905D

TC30_ng05D 270315-16

BULKHEAD PLATE

2 SCREWS

Fig. # 2

Burner/ Grate Installation

Fig. # 3

INTERFACE

MODULE

IGNITION

WIRE

(RED)

FLAME

SENSOR

WIRE

(WHITE)

4. Secure the electrical bulkhead plate

(Fig.#2) and gasket to the rebox. (2

screws) Attach the ignition and sensor

wirestothemodule.(Fig.#3).

5056.42905D

TC30_ng05D 270315-16

PILOT SUPPLY

TUBE

MAIN GAS SUPPLY

TUBE

Fig. # 4

5. Attachthepilotandgassupplytubesto

the bulk head tting and tighten.

 (Fig.#3b)Ensuretheconnectionsare

gas tight. Conceal the spark and

sensor wires below the supply tubes.

A panel set must now be installed. See

Installation and Operating Instructions

manual for details.

6. Position the slots of the grate securing

brackets over the holes in the oor shield

and secure with the two screws

 (Fig.#4).

Fig. # 3b

5056.42905D

TC30_ng05D 270315-16

Note:

Ember material placement

and amount will affect

ame appearance.

More ember material

results in lower ame

height.

Add or remove as needed

until desired ame affect.

Reduce the amount used

on Propane models, as too

much will create soot

Fig. #5

Ember Material

Fig. #6

Alargebagofembermaterialisshippedwiththereplaceandneedstobeinstalledon

theburnertoensureoptimumperformanceandameappearance.Abagofcoalchunks

and lava rock is also supplied this must only be used around the burner pan to cover up

the gas lines and brackets.

1. Pullapartthematerialintoembersizepieces(approximately1”square)and

gently place them into the burner pan. Do not compress, leave them loose for best

performance.

2. Filltheburnerpanwithembersuntillevelwiththetopofthepanatrear,andgradually

slope forward to the rebox oor at the front, covering both burner tubes.

3. Placeremainingembermaterial,coalchunksandlavarockoutsideoftheburnerpan

as desired to cover-up gas lines and brackets. Do not put coal chunks or lava rock

inside burner pan as this will cause sooting and the burner to malfunction.

Embersonlyinthisarea.

Embers,coalchunksandlavarock.

5056.42905D

TC30_ng05D 270315-16

Gas plumbing and vent connections

should be completed before proceeding.

The logs are fragile, and should be handled

withcare.Unpackandinspectlogset.There

should be a total of seven logs.

Positionthelogsasindicatedbythefollowing

pictures.The seven main logs have holes and /

orpins.Engageeachpininthecorresponding

holes. The remaining two logs do not have

holesorpins.Theyrestinposition.Locate

asperthediagrams(g.#7-15)

Note: Improper placement of logs

will cause sooting on internal parts

and glass. The logs may need to be

repositioned slightly to avoid excessive

ame impingement.

Log Placement

Fig. # 7

Fig. # 8

BASE LOG, #1

LEFT CENTER LOG, #2

5056.42905D

TC30_ng05D 270315-16

Fig. #9

Fig. #10

LEFT FRONT LOG, #3

LOG WITH HOLE, #4

5056.42905D

TC30_ng05D 270315-16

Fig. #11

Fig. #12

RIGHT CENTER LOG, #5

FRONT RIGHT LOG, #6

5056.42905D

TC30_ng05D 270315-16

FRONT RIGHT LOG, #6

Fig. #14

Fig. #15

Fig. #13

CENTER TWIG, #8

RIGHT BASE LOG, #7

CENTER BASE CHUNK, #9

Propane Conversion

If the unit is to be used on propane,

convert as follows using the compo-

nents supplied with this replace:

Note:Factorysuppliedcomponentsmust

be used to ensure correct input.

Afterconversionconrmpropermanifold

pressure.

CAUTION

The gas supply and electrical power

must be shut off before proceeding

with the conversion.

Fig. # 17

Fig. # 18

Fig. # 16

WARNING

This conversion kit shall be

installed by a qualied

service agency in

accordance with the

manufacturer's instructions

and all applicable codes

and requirements of the

authority having

jurisdiction.

If the information in these

instructions is not followed

exactly, a re, explosion or

production of carbon

monoxide may result

causing property damage,

personal injury or loss of

life.

The qualied service

agency is responsible for

the proper installation of

this kit.

The installation is not

proper and complete un-

til the operation of the

converted appliance is

checked as specied in the

manufacturer's instructions

supplied with the kit.

1. Ensuretheburner,pilotandgas

supply are turned off, and the

appliance has cooled.

2. Remove the two screws securing the

manifold assembly to the burner.

 (Fig.#16)

3. Remove the manifold assembly from the

burner.(Fig.#17)

4. Witha½”wrenchremovethenaturalgas

orice and replace with propane orice

(1.9mm)(ourpart#5022.76)

 (Fig.#18)

5. Fullyopentheprimaryairshutter.

6. Reinstall the manifold assembly and

air deector.

MAINBURNER(1.90mm)

ORIFICE(5022.76)

5056.42905D

TC30_ng05D 270315-16

Inhaltsverzeichnis

Andere Town & Country Fireplaces Kamin im Innenbereich Handbücher

Town & Country Fireplaces

Town & Country Fireplaces TC36ST Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.OD Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces Series C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS38 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC54 SERIES DMODULAR Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces D Series Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces D2 Series Installations- und Betriebshandbuch

Town & Country Fireplaces

Town & Country Fireplaces HELIFIRE 360 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54NG03C2 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS38 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54CODE Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 AR Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 TC36ST.NGST03D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCW120 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 SEE-THRUC SERIES Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Gebrauchsanweisung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54NG04.C2 Technisches Handbuch

Town & Country Fireplaces

Town & Country Fireplaces TC54 SERIES DMODULAR Gebrauchsanweisung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch