Assa Abloy RIXSON 185 Quick Spotter Bedienungsanleitung

Note:

1. Do not scale drawing.

2. Dimensions given in inches. Conversion from inches to metric: inch x 25.4.

3. If necessary to prevent cement from entering foundation case, apply duct tape to

seal the gap between closer and foundation case.

10-1/2

12-1/2

9-1/2

12-1/2

4-1/2" Deep

Concrete pour should not go past expansion joint.

4" to outside of building/5-1/2 to inside.

4-1/2" Deep

Installation Instructions

40016 (03-09)

185 Quick Spotter

For use with

Closer Models 25, 26, 27,

30, & 40

Cement Cases 79501 & 1101

28,

866-474-9766 Technical Department

www.rixson.com

5/88

Closer

No. 30

No. 40

4-1/2

7-1/2

15-1/2

Figure 1

Figure 1A

COVER

ANCHORS

COMPLETELY

WITH CEMENT

4-1/2

7-1/2

12-1/2

30/40 Cement Case 25-28 Cement Case

Blocking Instructions

Check template for location of rough hole.

79501 Cement Case 1101 Cement Case

ASSA ABLOY

RIXSON®

40016 (03-09)

Kit includes:

4 ea 1/4 -20 x 3/4 Flat Head Phillips Screws

4 ea #10-24 x 5/16 Round Head Phillips Screws

4 ea #10-24 x 3/4 Hex Washer Head Screws

2 ea Straps

1 Spindle locator 3/4 offset

1 Spindle locator 2-3/4 center hung

1 Bubble level

Spindle

Locator

Level

866-474-9766 Technical Department

www.rixson.com

No. 30/40 Closers

Non-Handed

Strap

Mounting

Screw

Strap

Concrete Anchor (if needed)

Leveling ScrewLeveling Screw

Concrete Anchor (if needed)

Leveling Screw

40016 (03-09)

No. 25-27

Offset Closers

Right Hand Shown

3/4 Offset Only

No. 26-28

Center Hung Closers

Spindle

Spindle Locator

Level

Spindle

Spindle Locator

Level

866-474-9766 Technical Department

www.rixson.com

Strap

Mounting

Screw

Strap

Leveling Screw

Strap

Mounting

Screw

Strap

Leveling Screw

Concrete Anchor (if needed)

Leveling Screw

Concrete Anchor

(if needed)

Leveling Screw

Concrete Anchor (if needed)

Concrete Anchor

(if needed)

40016 (03-09)

1. With frame set in place, cut hole in floor to

dimensions for closer model on page 1;

Figure 1. Clean out excess concrete.

2. Install top pivot in frame.

3. Drop plumb line from top pivot. See Figure 2 at

right. (Use of Rixson 2604 Pivot Aligning Tool is

recommended)

4. Place closer in cement case and attach with 4

each 1/4-20 x 3/4 Flat Head Phillips screws.

See Figure 3 at right.

5. Place straps on top of cement case and center

each.

6. Using 10-24 x 5/16 round head screws, tighten

straps to top of closer.

7. Set closer/foundation case in hole in floor.

8. Put spindle locator over spindle and position

closer next to frame. See appropriate closer

model illustration on previous pages.

9. Make sure that plumb line is centered over

spindle.

10.Place bubble level on top of closer spindle and

torpedo level. See Figure 4 at right.

11.Using 4 leveling screws (10-24 x 3/4 hex

washer head screws), turn screws to raise and

lower straps until closer is completely level.

This is determined by bubble level provided.

12.Re-check all areas, locator, plumb line and

level.

13.If needed, insert cement anchors to stabilize

installation.

Figure 3

#10-24 x 5/16

Strap Mounting Screw

Support

Strap

Finished

Floor

#10-24 x 3/4

Leveling Screw

Figure 4

LEVEL IN BOTH

DIRECTIONS

Top Pivot Jamb Portion

Intermediate

(Side Jamb)

Pivot

Cement Case

RIGHT HAND installation

Plumb Line

Installation:

Figure 2

14.Use two pour grouting procedure:

Use EXPANDABLE QUICKSET CEMENT, (Por-Rok or equivalent grout). Grout in only bottom

3/4" of foundation case, including bottom of cement anchor. Allow grout to harden.

15. Hang door.

16. Use a regular cement mixture, EXTERIOR TYPE (Sakrete or equivalent) to finish setting the

foundation case. ALL 4 ANCHORS MUST BE COMPLETELY COVERED WITH CEMENT.

(See Figure 1A on page 1)

Step 1

Step 2

866-474-9766 Technical Department

www.rixson.com

40016 (03-09)

Andere Assa Abloy Türöffnungssystem Handbücher

Assa Abloy

Assa Abloy Norton 6300 Series Bedienungsanleitung

Assa Abloy

Assa Abloy SARGENT 1331 Bedienungsanleitung

Assa Abloy

Assa Abloy DC135 Service-Handbuch

Assa Abloy

Assa Abloy besam PUSH-N-GO Bedienungsanleitung

Assa Abloy

Assa Abloy Corbin Russwin PED5400 FE Bedienungsanleitung

Assa Abloy

Assa Abloy SARGENT 3828 Series Bedienungsanleitung

Assa Abloy

Assa Abloy Adams Rite EX89 Betriebsanleitung

Assa Abloy

Assa Abloy 1370 Bedienungsanleitung

Assa Abloy

Assa Abloy Corbin Russwin PED5000 DB Series Bedienungsanleitung

Assa Abloy

Assa Abloy Norton J1600 UniTrol Bedienungsanleitung

Assa Abloy

Assa Abloy Norton 5630 Series Kurzanleitung

Assa Abloy

Assa Abloy Norton 6300 Series Kurzanleitung

Assa Abloy

Assa Abloy SARGENT FIREGUARD 12-2468 Bedienungsanleitung

Assa Abloy

Assa Abloy SW60 Handbuch

Assa Abloy

Assa Abloy SW200 Bedienungsanleitung

Assa Abloy

Assa Abloy Norton PR7500 Bedienungsanleitung

Assa Abloy

Assa Abloy Norton 5700P Series Bedienungsanleitung

Assa Abloy

Assa Abloy ABLOY DA401 Bedienungsanleitung

Assa Abloy

Assa Abloy DC700G-E Bedienungsanleitung

Assa Abloy

Assa Abloy Norton 6300 Series Installationshandbuch

Assa Abloy

Assa Abloy SARGENT 2900 FIREGUARD Bedienungsanleitung

Assa Abloy

Assa Abloy SARGENT 1431 Series Bedienungsanleitung

Assa Abloy

Assa Abloy Pando Mini Go Bedienungsanleitung

Assa Abloy

Assa Abloy Sargent PE8800 Series Bedienungsanleitung

Beliebte Türöffnungssystem Handbücher anderer Marken

Pamex

Pamex KT-INP35 Bedienungsanleitung

Cal-Royal

Cal-Royal N-F77CVR Bedienungsanleitung

Scrigno

Scrigno OPEN1000 Bedienungsanleitung

TriMark

TriMark UM 34 Bedienungsanleitung

BFT

BFT WIND RMB 130B 200 Bedienungsanleitung

Alecto

Alecto ADI-250 Bedienungsanleitung

Besam

Besam Swingmaster MP Leitfaden

CRL

CRL SENIOR PRIMA Bedienungsanleitung

GAL

GAL MOVFR Technisches Datenblatt

Normstahl

Normstahl IDO7 Bedienungsanleitung

Häfele

Häfele Finetta T 70 VF Bedienungsanleitung

AGS

AGS D-PL Handbuch

Stanley

Stanley MA900ñ Montageanleitung

WITTUR

WITTUR Hydra Plus UD300 Handbuch

Alutech

Alutech TR-3019-230E-ICU Montage- und Bedienungsanleitung

MPC

MPC ATD ACTUATOR 50 ATD-313186 Operating and Technisches Datenblatt

GEZE

GEZE ECturn Bedienungsanleitung

Chamberlain

Chamberlain T Bedienungsanleitung