Medline HCS70004 Bedienungsanleitung

HCS70004P, HCS70004G

HCS70004C, HCS70004BL

HCS70004DP, HCS70004

AEROMIST

Instruction Manual

COLORS™

NEBULIZER

COMPRESSOR KIT

HCS70004P, HCS70004G

HCS70004C, HCS70004BL

HCS70004DP, HCS70004

TABLE OF CONTENTS

IEC Symbols.......................................................................................................2

Important Safeguards.....................................................................................2

Introduction.......................................................................................................3

Speciﬁcations....................................................................................................4

Description.........................................................................................................5

Operation Instructions....................................................................................6

Cleaning..............................................................................................................7

Maintenance......................................................................................................7

Trouble Shooting Guide...................................................................................8

Warranty.............................................................................................................9

AEROMIST

Instruction Manual

IMPORTANT WARNINGS

Caution:

1. Federal Law (USA) restricts this device for sale or use on the order of a

physician.

2. Follow the instructions of your physician to operate this unit.

3. This product is a nebulizer for the inhalation of medical aerosols and is

suitable for all commonly used solutions. Use only the type and amount of

medication prescribed by your doctor.

4. This product is intended for aerosol therapy only. Any other use is not

recommended.

5. Do not untwist the jet nebulizer during operation.

6. Do not pour more than 10 mL of solution into the jet nebulizer.

Danger: To Reduce the risk of electrocution

7. Always unplug the unit immediately after using.

8. Do not use while bathing.

9. Do not place or store the unit where it can fall or be pulled into a tub or sink.

10. Do not place or drop into water or other liquid.

11. Do not reach for a product that has fallen into water. Unplug immediately.

IEC SYMBOLS

Caution, Attention or Consult accompanying documents..................

Type BF Equipment.....................................................................................

Alternating Current.....................................................................................

Double Insulation.........................................................................................

Indoor Use Only............................................................................................

IEC SYMBOLS

Caution, Attention or Consult accompanying documents..................

Type BF Equipment.....................................................................................

Alternating Current.....................................................................................

Double Insulation.........................................................................................

Indoor Use Only............................................................................................

Warning: To Reduce the risk of burns, electrocution,

ﬁre or injury

1. Electrical Shock Hazard - do not remove the cabinet or open the cover.

2. Disconnect the power cord from the electrical outlet before cleaning or

servicing.

3. Do not place this equipment near hot, sparking or burning objects

4. Do not use oil or grease on or near this device.

5. Turn the unit off when it is not in use.

6. Keep the cord away from HEATED or HOT surfaces.

7. NEVER drop or insert any object into any opening.

8. NEVER block the air openings of the product or place it on a soft surface,

such as a bed or couch, where the air opening may be blocked.

9. Avoid operating in wet or damp locations.

10. Unplug the unit before ﬁlling the nebulizer.

Warning: To reduce the risk of infection:

Cleaning of the nebulizer is recommended after each aerosol treatment.

Disinfecting is recommended once a day. Please follow cleaning and

disinfecting instructions in this manual.

INTRODUCTION

This compressor nebulizer is designed to deliver the prescribed medication

solution to treat your respiratory disorders: such as asthma, allergies, and

bronchitis. The nebulizer converts the medication solution into an aerosolized

mist which is inhaled by the patient through the mouthpiece. Read this manual

thoroughly before using the nebulizer and save for future reference.

SPECIFICATIONS

Items HCS70004P, HCS70004G, HCS70004BL,

HCS70004C, HCS70004DP, HCS70004

Current 120V/60HZ

Power consumptiont 180 VA Max

Nebulize Cup #30503

Operation air pressure 9 - 16 Psi (62 - 110 kPa)

Max air pressure 35 - 50 Psi (241 - 345 kPa)

Operation Air Flow 5.0 - 8.0 Lpm

Nebulizer rate ≥ 0.18mL/min (2% saline)

Noise level ≤ 55 dB

Operation R.H. 30 - 85% RH

Operation temperature 10 - 40 °C (50 - 104 °F)

Storage R.H. 30 - 85% RH

Storage temperature -20 - 70 °C (-4 - 158 °F)

Dimensions(L x W x H) 150 x 140 x 90 mm

Weight 1.2 kg

(1). Conditions may vary based on altitude above sea level, barometric

pressure air temperature. Speciﬁcations subject to change without

notice.

(2). Nebulizer speciﬁcations may vary with the kind of medication being

used and its viscosity.

(3). For electromagnetic compatibility the standards are based as follow:

IEC/EN 60601-1-2.

(4). Protection against electric shock is classiﬁed as Type II.

(5). Degree of protection against electric shock is classiﬁed as Type BF.

(6). Equipment not suitable for use in the presence of a ﬂammable anesthetic

mixture with air, oxygen, or nitrous oxide.

DESCRIPTION

Power Switch

Air Outlet

Connector

Filter Cap

Power Cord

Compressor

Mouthpiece

+ reservoir

tubing

Jet Nebulizer

Cap

Bafﬂe

Jet Nebulizer

Chamber

Air Inlet

Connector

Tubing

Foam Filters

OPERATION INSTRUCTIONS

1. Place compressor on a stable, sturdy and ﬂat surface such that the unit can

be easily reached when you’re seated.

2. Make sure the compressor is off by pressing the power switch to the “OFF”

(O) position.

3. Plug power cord into a wall outlet.

4. Connect one end of the tubing into the compressor air outlet connector.

5. Add the prescribed solution through the opening on jet nebulizer cap using

an eye dropper or pre-measured dose container.

6. Assemble mouthpiece onto the top of the jet nebulizer cap. If an aerosol

mask is used, connect the bottom of mask to the top of jet nebulizer cap.

7. Connect tubing to jet nebulizer air inlet connector.

8. Turn the compressor on by pressing power switch to “ON” (I) position.

9. Implement the treatment by placing the mouthpiece between the teeth.

Inhale and exhale through the mouthpiece.

10. If an aerosol mask is used, place the mask over the mouth and nose.

Note: The compressor motor has a thermal protector which will shut off the

unit before the unit overheats. When the thermal protector shuts the unit off:

1) Switch off the unit, 2) Unplug the unit from the electrical outlet, 3) Wait 30

minutes for the motor to cool down before another treatment.

CLEANING

1. Turn the power off and unplug the compressor power cord from the wall

outlet.

2. Remove the tubing from the air inlet.

3. TO CLEAN: Disassemble mouthpiece, jet nebulizer cap, chamber and bafﬂe,

and wash these items in hot water with dish-washing detergent. Rinse

these items thoroughly to remove the detergent and let air dry.

4. TO DISINFECT: Mix 1/4 cup of white vinegar with 3/4 cup hot water in a

clean container. Submerge mouthpiece, T-piece, nebulizer cap, chamber and

bafﬂe for 30 minutes in the solution. Remove from solution and let air dry.

5. There is no need to clean the tubing. If necessary wipe the surface regularly.

CAUTION: The jet nebulizer must be changed if it gets clogged.

CAUTION: The nebulizer and accessories must not be boiled.

MAINTENANCE

1. The air compressor ﬁlter should be replaced when it turns gray.

Additional ﬁlters can be purchased from your dealer.

2. Only authorized personnel shall make repairs to this product.

CAUTION: The nebulizer may be damaged if used with a dirty ﬁlter or if

the ﬁlter is replaced by other material such as cotton. Do NOT operate without

a ﬁlter.

TROUBLE SHOOTING GUIDE

If a problem occurs during operation, please check and correct the following

points:

SYMPTOM POSSIBLE

CAUSE

SUGGESTED

SOLUTIONS

When switching it

on, it does not work.

Incorrectly plugged. Check if the unit is

properly connected.

The mist does not

come out from

the jet nebulizer/

aerosol output

reduced (low).

1. Incorrect amount

of medication in the

jet nebulizer.

2. Tubing disconnected.

3. The jet nebulizer is

not creating mist.

4. The air ﬁlter is clogged.

1. The jet nebulizer’s

maximum capacity

is 10mL. Adjust the

volume until the

nebulizer functions

correctly.

2. Connect the tubing.

3. Replace the jet

nebuilzer.

4. Replace the air ﬁlter.

WARRANTY

Medline Industries, Inc. warrants the nebulizer compressor to be free from

defective workmanship and materials for a period of (5) years from the date of

purchase. Check with your dealer for more details. This warranty is limited to

the original purchaser of the compressor. Any defective part or assembly will

be repaired or replaced, at the sole discretion and determination of Medline

Industries, Inc., if the unit has been properly operated during the warranty

period. Normal maintenance items and disposable components are not covered

by this warranty. Shipping charges, if any, shall be paid by the purchaser.

Note: There is no other express warranty. Implied warranties, including those

of merchantability and ﬁtness for a particular purpose, are limited to the

duration of the express limited warranty and to the extent permitted by law

and all implied warranties are excluded. This warranty does not cover providing

a loaner compressor, compensating for costs incurred for compressor rental, or

labor costs incurred in repairing or replacing defective part(s).

www.medline.com

Aeromist Colors™ is a trademark and Medline is

a registered trademark of Medline Industries, Inc.

Manufactured for: Medline Industries, Inc.

Three Lakes Drive, Northﬁeld, IL 60093 USA

Product of China. 1-800-MEDLINE RD17ZBI

Inhaltsverzeichnis

Andere Medline Medizinische Geräte Handbücher

Medline

Medline ComfortGlide Bedienungsanleitung

Medline

Medline Microban MDS86960KDMB Bedienungsanleitung

Medline

Medline HCSM70C Bedienungsanleitung

Medline

Medline MDS400SAB Bedienungsanleitung

Medline

Medline HCSM70P Bedienungsanleitung

Medline

Medline SwivAssist Bar Bedienungsanleitung

Medline

Medline Compat DualFlo 9521437 Bedienungsanleitung

Medline

Medline MDS705154 Bedienungsanleitung

Medline

Medline HEMO-FORCE MDS600INT2 Bedienungsanleitung

Medline

Medline Patient Lift Bedienerhandbuch

Medline

Medline OR212 Bedienungsanleitung

Medline

Medline MDS400ELB Bedienungsanleitung

Medline

Medline HCSFSATSPORT Bedienungsanleitung

Medline

Medline HCSM70 Bedienungsanleitung

Medline

Medline HCSMD400 Bedienungsanleitung

Medline

Medline Alterra MAXX Bedienungsanleitung

Medline

Medline Bed Assist Bar Bedienungsanleitung

Medline

Medline Alterra 1232 Bedienungsanleitung

Medline

Medline MDS80500 Bedienungsanleitung

Medline

Medline HUDSON RCI Neptune ConchaSmart HUD42500 Bedienungsanleitung

Medline

Medline HCS7000 Bedienungsanleitung

Medline

Medline EntraFloH2O Betriebsanleitung

Medline

Medline MDS80600 Bedienungsanleitung

Medline

Medline CompliMates Bedienungsanleitung

Beliebte Medizinische Geräte Handbücher anderer Marken

TekTone

TekTone Tek-CARE160 Bedienungsanleitung

NeuroMetrix

NeuroMetrix Quell 2.0 Bedienungsanleitung

AMT

AMT XLR8 Bedienungsanleitung

EDAN

EDAN SONOTRAX Pro Bedienungsanleitung

Restorative Therapies

Restorative Therapies RT300 Bedienungsanleitung

Gendex

Gendex Expert DC Bedienungsanleitung

Dexcowin

Dexcowin ADX4000W Bedienungsanleitung

Libelium

Libelium MySignals Bedienungsanleitung

Acelity

Acelity V.A.C.ULTA 4 Bedienungsanleitung

Caputron

Caputron ActivaDose II tDCS Bedienungsanleitung

Plinth 2000

Plinth 2000 93CDT Bedienungsanleitung

GE SENOGRAPHE 800T Bedienungsanleitung

GE Definium 5000 Bedienungsanleitung

Kanmed

Kanmed GE-1380 Bedienungsanleitung

Huntleigh

Huntleigh FD1 Bedienungsanleitung

Stryker

Stryker SPR Plus Bedienungsanleitung

Tobii Dynavox

Tobii Dynavox I-Series Bedienungsanleitung

S-Capepod

S-Capepod Evac Cocoon Bedienungsanleitung