Mercia Garden Products 0619VR3301-V1 Bedienungsanleitung

P 1

0619VR3301-V1

19MM LOG CABIN - 3.3X1M VERANDA ADD ON PACK B

2mm Drill bit

Winter = High Moisture = Expansion

Summer = Low Moisture = Contraction

All buildings should be

erected by two adults

For ease of assembly, you

MUST pilot drill all screw

holes and ensure all screw

heads are countersunk.

CAUTION

Every eort has been made during the

manufacturing process to eliminate the

prospect of splinters on rough surfaces of the

timber. You are strongly advised to wear gloves

when working with or handling rough sawn

timber.

Please retain product label and instructions for future reference

0619VR3301-V1

BEFORE YOU START PLEASE READ INSTRUCTIONS CAREFULLY

- Check the pack and make sure you have all the parts listed.

- When you are ready to start, make sure you have the right tools at hand (not supplied)

including a Phillips screwdriver, Stanley knife, wood saw, step ladder and drill with 2mm

bit.

- Ensure there is plenty of space and a clean dry area for assembly.

TIMBER

As with all natural materials, timber can be aected during various weather conditions.

For the duration of heavy or extended periods of rain, swelling of the wood panels may

occur. Warping of the wood may also occur during excessive dry spells due to an interior

moisture loss. Unfortunately, these processes cannot be avoided but can be helped. It is

suggested that the outdoor building is sprayed with water during extended periods of

warm sunshine and sheltered as much as possible during rain or snow.

BUILDING A BASE

When thinking about where the building and base are going to be constructed:

Ensure that there will be access (60mm) to all sides for maintenance work and annual

treatment.

Ensure the base is level and is built on rm ground, to prevent distortion. Refer to

diagrams for the base dimensions. The base should be slightly smaller than the external

measurement of the building, i.e. The cladding should overlap the base, creating a run

o for water. It is also recommended that the oor be at least 25mm above the

surrounding ground level to avoid ooding.

TYPES OF BASE

- Concrete 75mm laid on top of 75mm hard-core.

- Slabs laid on 50mm of sharp sand.

Whilst all products manufactured are made to the highest standards of Safety and in

the case of childrens products independently tested to EN71 level, we cannot accept

responsibility for your safety whilst erecting or using this product.

Refer to the instructions pages for your specic product code

For ease of assembly use a

rubber mallet to t the log

boards. Do NOT use a heavy

hammer.

Ensure to measure and check before cutting

boards.

It is advisable to use a hand

saw when cutting roof and

oor boards.

To ensure log boards are even, use a spirit

level to check each layer has been installed

correctly.

Measure

under the

head

Measure

overall

length

Screws & Nails Bolts To identify the

xings required

for each step use a

measuring tape.

For assistance please contact customer care on: 01636 821215

Mercia Garden Products Limited,

Sutton On Trent,

Newark,

Nottinghamshire,

NG23 6QN

www.merciagardenproducts.co.uk

P 2

0619VR3301-V1

Please retain product label and instructions for future reference

Overall Dimensions:

Width = 3258mm

Depth = 1000mm

Height = 870mm

Base Dimensions:

Width = 3230mm

Depth = 902mm

Before assembly

please make sure you have a

suitable base ready to erect your

building

MADE IN GREAT BRITAIN

Bearer - 44x44x3104mm QTY 3

F4444-3104-PT

Log Board - 110x19x326mm QTY 2

LB19RG110-B-326

Log Board - 120x19x326mm QTY 6

LB19-C-326

Log Board - 120x19x1000mm QTY 8

LB19-B-1000

Log Board - 56x19x1000mm QTY 2

LB19RG56-B-1000

Bearer - 44x44x247mm QTY 2

F4444-247-PT

Floor Board - 120x12x882mm QTY 25

S12120-882

Starter Board - 66x19x326mm QTY 2

LB19RT66-B-326

Log Board - 120x19x326mm QTY 18

LB19-B-326

EXAMPLE BUILDING

There may be extra screws present in the nail bag

70mm Screw x 12

Nail Bag

40mm Screw x 85

Pre-assembly

*Please note:

Each board interlocks at either end in a staggered pattern.

Before securing ensure that the boards are tted properly in

their respective tongues and grooves.

P 3

Please retain product label and instructions for future reference

Pre-Assembly

Follow the instructions for the 19mm Log Cabin

(0619AXNE3326HGDD2SW-V1 OR 0619AXNE3303HGDD2SW-V1)

Your Log cabin should be fully assembled before starting the Veranda.

Your building should look as shown.

Step 1

Parts Needed - No. 1 QTY 3

No. 2 QTY 2

Place the rst Bearer

(No. 1) up to the log cabin and x

to the log cabin bearer using

4x70mm screws.

Attach one small bearer

(No. 2) to each end of the third-

larger bearer using 4x70mm

screws.

8x70mm Screws

Pre drill

hole

70mm

screw

Please retain product label and instructions for future reference

70mm

screw

Pre drill

hole

40mm

screw

Step 2

Parts Needed - No. 4 QTY 2

No. 8 QTY 2

Following the method outlined

in the illustration, secure one

starter board (No. 4) onto each of

the small bearers (No. 2), using

1x70mm screws per board,

ensuring to screw through the

notch into the bearer below.

Make sure that the end of starter

board (No. 4) is ush with end of

the small bearer (No. 2.)

Place the rst two log boards

(No.8) onto the starter boards

(No.4) and rest onto the bearers as

shown in the illustration.

Once in position x the log board

to the inside of the cabin using

2x40mm screws per log board.

*The centre bearer at this

point is not xed into position,

arrange so that the bearer is

central.

4x40mm Screws

2x70mm Screws

P 4

Step 3

Parts Needed - No. 5 QTY 18

No. 6 QTY 2

No. 7 QTY 6

No. 8 QTY 6

Following the method outlined

in the illutration, continue placing

the boards (No. 5, 7 & 8) on to the

veranda sides as shown in the illus-

trations, ensuring to interlock the

boards.

Once in position x the top log

board (No.6) on each side to the

inside of the cabin using 2x40mm

screws per log board.

4x40mm Screws

Pre drill

hole

40mm

screw

Rubber Mallet

may be required

to t parts.

For assistance please contact customer care on: 01636 821215

Mercia Garden Products Limited,

Sutton On Trent,

Newark,

Nottinghamshire,

NG23 6QN

www.merciagardenproducts.co.uk

P 5

Please retain product label and instructions for future reference

Step 4

Parts Needed - No. 3 QTY 25

Place the Floor Boards (No. 3)

onto the bearers and secure each

board into place using 3x40mm

screws, ensuring to screw

through the boards into the bear-

ers below.

75x40mm Screws

40mm

screw

Pre drill

hole 3

Step 5

Parts Needed - No. 9 QTY 2

Fix the last two log boards (No.9)

onto the veranda sides using

1x70mm screws per board through

the notches and 2x40mm screws

per board through the boards as

shown in the illustration.

2x40mm Screws

2x70mm Screws

70mm

screw

Pre drill

hole

40mm

screw

Rubber Mallet

may be required

to t parts.

AFTER TREATMENT:

score around protective

cover on glazing and

carefuly peel

covering back

It is ESSENTIAL that you apply wood

treatment immediately after the building

has been assembled.

SILICONE

SEALANT

It is ESSENTIAL to seal around all window framing with

sillicone sealant (not included) to minimise water ingress.

Inhaltsverzeichnis

Andere Mercia Garden Products Gartenhaus Handbücher

Mercia Garden Products

Mercia Garden Products 0644RANE0504FGDD2TW1SW-V1 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 01BEACH-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 03HEL1008DDFW-V3 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 0628LOG127-V5 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products Rose Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 010VLPA0305SDNW-V1 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 03TGCOR0707-V5 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 0619WKNE2633LBDD1SW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01OVLPA0406DDNW-V Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01PTOSBA0806SDFW-V2 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 01DTOVRA1006SDFW-V1 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 01DDPENT1408-V3 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01DTPRMSHDB1008DDOP-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01GRO1008DD-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01DTSHPWOR1010DDOW-V4 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01PTSHPMOW4803-V2 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 03DTSHPN0408DSHPB-V1 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 01DTSHAX0305SDNW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 0644LOG186-V4 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 05DTMBAX0103SD-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01DTPRMSHPN1206DDOP-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01PTPOT0806-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01DTSHAX0406SDFW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01DTPRMSHDB0808DDOP-V1 Bedienungsanleitung

Beliebte Gartenhaus Handbücher anderer Marken

Lemeks

Lemeks Palmako PA120-5930-6 Installationshandbuch

Rion

Rion Hobby Gardener Bedienungsanleitung

Gartenhaus-King

Gartenhaus-King Valery Bedienungsanleitung

Select

Select ISAAC E9682 Bedienungsanleitung

Palmako

Palmako Saale Bedienungsanleitung

Lemeks

Lemeks Palmako Kira EL16-3623 Installationshandbuch

Palmako

Palmako Roger FR44-5953-2 Bedienungsanleitung

Pergola kits USA

Pergola kits USA PREMIUM VINYL PAVILION Bedienungsanleitung

G21

G21 Boston 882 Bedienungsanleitung

Lemeks

Lemeks Palmako Grace PM56-4529 Installationshandbuch

Shire

Shire Salcey Bedienungsanleitung

Rutland County

Rutland County Burley 6ft Bedienungsanleitung

Palmako

Palmako Roger 27,7 Bedienungsanleitung

Lemeks

Lemeks Palmako PA120-5930-9 Installationshandbuch

Lemeks

Lemeks Palmako PM70-6436 Installationshandbuch

Lemeks

Lemeks Palmako PM56-4435 Installationshandbuch

Lemeks

Lemeks 106214 Installationshandbuch

POD

POD Camping 480 Bedienungsanleitung