Mercia Garden Products HONEYSUCKLE PLAYHOUSE Gebrauchsanweisung

P 1

02HON51156

HONEYSUCKLE PLAYHOUSE

2mm Drill bit

x2 Winter = High Moisture = Expansion

Summer = Low Moisture = Contraction

All building’s should be

erected by two adults

For ease of assembly, you

MUST pilot drill all screw

holes and ensure all screw

heads are countersunk.

For assistance please contact customer care on: 01636 880514

Mercia Garden Products Limited,

Sutton On Trent,

Newark,

Nottinghamshire,

NG23 6QN

www.merciagardenproducts.co.uk

CAUTION

Every eort has been made during the

manufacturing process to eliminate the

prospect of splinters on rough surfaces of the

timber. You are strongly advised to wear gloves

when working with or handling rough sawn

timber.

**Protim Aquatan T5 (621)**

Your building has been treated with Aquatan.

Aquatan is a water-based concentrate which is diluted with water, the building as been treated by the correct

application of Aquatan solution and then allowed to dry.

Aquatan is a decorative nish to colour the wood, which is applied industrially to timber fence panels and

garden buildings.

Aquatan undiluted contains: boric acid, sodium hydroxide 32% solution, aqueos mixture of sodium dioctyl

sulphosuccinat and alcohols: 2, 4, 6-trichlorophenol.

Please retain product label and instructions for future reference

General Instructions

BEFORE YOU START PLEASE READ INSTRUCTIONS CAREFULLY

- Check the pack and make sure you have all the parts listed.

- When you are ready to start, make sure you have the right tools at hand (not supplied)

including a Phillips screwdriver, Stanley knife, wood saw, step ladder and drill with 2mm

bit.

- Ensure there is plenty of space and a clean dry area for assembly.

TIMBER

As with all natural materials, timber can be aected during various weather conditions.

For the duration of heavy or extended periods of rain, swelling of the wood panels may

occur. Warping of the wood may also occur during excessive dry spells due to an interior

moisture loss. Unfortunately, these processes cannot be avoided but can be helped. It is

suggested that the outdoor building is sprayed with water during extended periods of

warm sunshine and sheltered as much as possible during rain or snow.

Our buildings are pre treated with a water based treatment**; this only helps to protect

the product during transit and for upto 3 months against mould. To validate your

guarantee and ensure longevity of the product, it is ESSENTIAL the building is treated

with a wood preserver within the rst three months of assembly and thereafter in

accordance with the manufactures recommendations. Care must be taken to ensure

the product is placed on a suitable base.

BUILDING A BASE

When thinking about where the building and base is going to be constructed:

Ensure that there will be access to all sides for maintenance work and annual

treatment.

Ensure the base is level and is built on rm ground, to prevent distortion. Refer to

diagrams for the base dimensions, The base should be slightly smaller than the external

measurement of the building, i.e. The cladding should overlap the base, creating a run

o for water. It is also recommended that the oor be at least 25mm above the

surrounding ground level to avoid ooding.

TYPES OF BASE

- Concrete 75mm laid on top of 75mm hard-core.

- Slabs laid on 50mm of sharp sand.

Whilst all products manufactured are made to the highest standards of Safety and in

the case of childrens products independently tested to EN71 level, we cannot accept

responsibility for your safety whilst erecting or using this product.

Refer to the instructions pages for you specic product code

For ease of assembly, you

will need a tape measure to

check dimensions of

components.

WARNING: Only for domestic use

Not suitable for children under 36 month

To be used under direct supervision of an adult

P 2

02HON51156-V2

Overall Dimensions:

Width = 1864mm

Depth = 1695mm

Height = 1711mm

Base Dimensions:

Width = 1760mm

Depth = 1670mm

Please retain product label and instructions for future reference

Before assembly

please make sure you have a

suitable base ready to erect your

building

MADE IN GREAT BRITAIN

Door gable

123

Plain gable Roof OSB

Left side panel Right side panel

Floor Sheet

Door

Roof support bar- 1100mm

Fascia board x4

Fascia block

Ply triangle

Roof eaves - 1670mm x2

Finial x2

Floor Joist - 1760mm x4

Fixing kit

Window cross x2 Ply ower Door Glazing

16 17

Corner

Bracing

Wooden door

handle

Felt

18 19

Hinge x2

QTY x2

Window

AI-02PHOW-V1

PI-07-0011

Window Block

QTY x4

P 3

Please retain product label and instructions for future reference

50mm Screw x 30

40mm Screw x 40

Felt Tacks x 65

20mm Screw x 15

30mm Screw x 57

60mm Screw x 2

30mm Black Screw x 14

PI-02-0352Nail Bag

Pre Assembly

Before assembling remove the transportation

blocks from the bottom of each panel.

10mm Screw x 4

Step 1

To x the Windows (No. 22) into the panels

that accomodate a window. First x the

Window Block to the Window as shown

with 1x30mm screw.

Place the Window into the window hole

and x by screwing though the Window

Block (No. 23) with 2x30mm screws as

shown.

Screw into the Window rst.

12x30mm screws.

Pre drill

hole

30mm

screw

Step 2

Lay joists (No. 10) under the oor sheet with an

even space between each one. Position

joists ush on one side of the oor sheet

and mark centers of joists onto either end.

Fix using 5 x 30mm screws per joist.

If purchased with a tower please read

both sets of instructions before

beginning assembly.

20x30mm screws.

Step 3

Lay the door gable face up on a at

surface, place the door within the door

aperture. Position the door so that you

have a 12mm gap from the door to the

door gable on all four sides.

Useful tip: Use a12mm thick piece of

timber from your xing kit within the

gaps to ensure the door does not

move.

Once you are happy the door is in the

correct position place a hinge at the top

and bottom of the door, ensuring the

screws will go into the framing (in cases

where you have been supplied three

hinges use the third in the middle of the

door) and using 30mm black screws x

the hinge to the door and the door gable.

14x30mm black screws

Pre drill

hole

30mm

screw

Pre drill

hole

30mm

screw

P 4

For assistance please contact customer care on: 01636 880514

Mercia Garden Products Limited,

Sutton On Trent,

Newark,

Nottinghamshire,

NG23 6QN

www.merciagardenproducts.co.uk

Please retain product label and instructions for future reference

Step 4

Fix the corner of the Plain Gable (No. 2) to the

Right Side Panel (No. 6) with 3x 50mm screws

as shown in diagram.

Do not secure the building to the oor until

the roof is tted.

3x50mm screws.

Step 5

Fix Door Gable (No. 1) to the Right Side Panel

(No. 6) and the Left Side Panel (No. 5) before

xing the Left Side Panel to the Plain Gable

in the corners using 12x50mm screws.

Position the panels so there is equal spacing

between the oor and cladding on all four sides.

Do not secure the building to the oor until

the roof is tted.

12x50mm screws.

Step 6

Place the Roof Support bar(No. 9) in between

the Door Gable(No. 1) and Plain Gable(No. 2)

panels. Ensure the top corners of the support

bar are ush with each top point. Secure in

place using the L Bracket(No. 20) on each

end with 4x30mm screws.

Do not secure the building to the oor until

the roof is tted.

8x30mm screws.

Step 7

Fix the Roof Eaves(No. 8) to each sheet using

3x30mm screws per eave.

Fix the Roof Sheets(No. 3) to the roof using 40mm

screws directly through the OSB into the

framing.

Do not secure the building to the oor

until the roof is tted.

6x30mm screws.

24x40mm screws.

40mm

screw

Pre drill

hole

30mm

screw

30mm

screw

Pre drill

hole

50mm

screw

Pre drill

hole

50mm

screw

Pre drill

hole

20mm

screw

P 5

Please retain product label and instructions for future reference

Step 8

Fit the Fascia Block (No. 12) to the front

of the building using 4x30mm screws, make

sure it is ush with the outside edge of each

roof sheet.

4x30mm screws.

Step 9

Cut Felt (No. 18) into 3 sheets and lay onto

roof as shown in diagram ensuring there is a

50mm overhang around the sides.

Fix using felt tacks at 100mm intervals.

60x Felt tacks

Felt

tacks

Step 10

Fix Fascias (No. 11) and Finials (No. 14) using

40mm screws. Pre drill holes to avoid splitting.

Ensure to the trap the felt between the

fascia and building.

12x40mm screws.

Step 11

Place a Window Cross(No. 15) against the

inside of each window. Position the frame

centrally to the window and x using

4x20mm screws per frame.

8x20mm screws.

Pre drill

hole

40mm

screw

Pre drill

hole

30mm

screw

Pre drill

hole

It is ESSENTIAL that you apply wood

treatment immediately after the building

has been assembled.

AFTER TREATMENT:

score around protective

cover on glazing and

carefuly peel

covering back

20mm

screw 10mm

screw

60mm

screw

P 6

Please retain product label and instructions for future reference

Step 12

Place the wooden door handle (No. 19)

on the outside of door and use a 60mm

screw from the inside to secure. Pre drill

hole rst to avoid splitting.

On the inside of the door opening x

the ply triangle door stop (No. 13) to the

bottom left corner using 3x20mm screws.

Sandwich the door glazing (No. 17) between

the door cut out and ower (No. 16),

then x using 3 x 10mm screws. Ensure

the glazing covers the cut out and the

screws do not hit and crack the glazing.

15x20mm screws.

3x10mm screws.

1x60mm screw.

Pre drill

hole

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Mercia Garden Products Gartenhaus Handbücher

Mercia Garden Products

Mercia Garden Products 01OVLPA1208DDFW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01DTOVAX1006DDFW-V1 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 0628LOG175-V4 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01RAW1210DDOW-V3 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01OVLPA1006DDFW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01GRODB1008-V4 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01OVLPA0705SDFW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 03DTSHCR0909FGD4TW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 04VCGRO-V3 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01PTOSBA1008DDFW-V1 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 01DTSHRAX0604SDNW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 8x8 Helios Summerhouse Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01DTSHAX0608SDFW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 03DTSHPN1008FGC31TWSA-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01DTSHAX0806SDSEC-V2 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 0644LOG213-V4 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products GROUNDSMAN 10 X 8 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 01OAOSB0702PB-V2 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 0628LOG131-V4 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products BOURNEMOUTH 03BRN0807-V4 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 01MODP0804-V2 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 01PTJER0806-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 02DTSHOA08066WBF-V1-PEFC Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 0628LOG181-V4 Bedienungsanleitung

Beliebte Gartenhaus Handbücher anderer Marken

Lemeks

Lemeks Palmako PA120-5930-6 Installationshandbuch

Rion

Rion Hobby Gardener Bedienungsanleitung

Gartenhaus-King

Gartenhaus-King Valery Bedienungsanleitung

Select

Select ISAAC E9682 Bedienungsanleitung

Palmako

Palmako Saale Bedienungsanleitung

Lemeks

Lemeks Palmako Kira EL16-3623 Installationshandbuch

Palmako

Palmako Roger FR44-5953-2 Bedienungsanleitung

Pergola kits USA

Pergola kits USA PREMIUM VINYL PAVILION Bedienungsanleitung

G21

G21 Boston 882 Bedienungsanleitung

Lemeks

Lemeks Palmako Grace PM56-4529 Installationshandbuch

Shire

Shire Salcey Bedienungsanleitung

Rutland County

Rutland County Burley 6ft Bedienungsanleitung

Palmako

Palmako Roger 27,7 Bedienungsanleitung

Lemeks

Lemeks Palmako PA120-5930-9 Installationshandbuch

Lemeks

Lemeks Palmako PM70-6436 Installationshandbuch

Lemeks

Lemeks Palmako PM56-4435 Installationshandbuch

Lemeks

Lemeks 106214 Installationshandbuch

POD

POD Camping 480 Bedienungsanleitung