Ski-Doo 1982 Blizzard 9500 Bedienungsanleitung

1982

OPERATOR1S

MANUAL

B/izzanl

®*Trademarks of Bombardier Inc.

Litho'd

Canada

All

nqhts

reserved (&)

Bombarrnet

Inc 414456200

model

V.I.N.

purchase date _

warranty expiry date

To be completed by dealer at time of sale.

DEALER IMPRINT AREA

MOTO-SKI

FUTURA

SPIRIT

NUVIK

MIRAGE

SUPER SONIC

ULTRA SONIC

SONIC

TECHNICAL PUBLICATIONS

AFTER SALES SERVICE DEPARTMENT

BOMBARDIER INC.

VALCOURT, QUEBEC

CANADA,

JOE2LO

The following are trademarks of Bom-

bardier Inc.

BOMBARDIER EVEREST

SKI-DOO CITATION

ALPINE OLYMPIQUE

BLIZZARD

T'NT

CARRY-BOOSE NORDIK

ELAN SKANDIC

ELITE

GRAND PRIX SPECIAL

FOREWORD

The Operator Manual and the Snow-

mobile Safety handbook have been

prepared to acquaint the owner Ioper-

ator of a new snowmobile with the var-

ious vehicle controls maintenance and

safe operating instructions. Each is in-

dispensable for the proper use of the

product, and should be kept with the

vehicle at all times.

Should you have any questions per-

taining to the warranty and its applica-

tion, please consult the

"Often

Asked

Question" section of this manual, or

your selling dealer.

This manual uses the following sym-

bols.

......

WARNING:

Identifies an instruc-

.....

tion which, if not followed, could

cause personal injury.

_CAUTION: Denotes an instruc-

" tion which, if not followed, could

severely damage vehicle components.

ONOTE: Indicates supplementary

information needed to fully com-

plete an instruction.

Although the mere reading of such in-

formation does not eliminate the haz-

ard, your understanding of the infor-

mation will promote its correct use.

SAFETY

MAINTENANCE

Observe the following

precautions:

• Throttle mechanism should be check-

ed for free movement before starting

engine.

• The snowmobile engine can be

stopped by activating the emergen-

cy cut-out or tether switches or turn-

ing

off

the key.

• Clean and check operation of the

headlight, tail light and brake light.

• Engine should be running only when

pulley guard is secured in place.

• Never run the engine

without

drive

belt installed. Running an unloaded

engine can prove to be dangerous.

• Never run the engine when the track

is raised

off

the ground.

• It can be dangerous to run engine

with the hood removed.

• Gasoline is flammable and explosive

under certain conditions. Always

manipulate in a well ventilated area.

Do not smoke or allow open flames

or sparks in the vicinity. If gasoline

fumes are noticed while driving, the

cause should be determined and

corrected

without

delay.

• Maintain your vehicle in top mechan-

ical condition at all times.

• Your snowmobile is not designed to

be driven or operated on black top,

bare earth, or other abrasive sur-

faces. On such surfaces abnormal

and excessive wear of critical parts

is inevitable.

• Your snowmobile is not designed to

be operated on public streets, road

or highways. In most States and

Provinces, it is considered an illegal

operation.

• Installation of other than standard

equipment, including ski-spreaders,

bumpers, pack racks, etc., could

severely affect the stability and safe-

ty of your vehicle. Avoid adding on

accessories that alter the basic ve-

hicle configuration.

•Whenever the vehicle is parked out-

doors, overnight or for a long peri-

od, it issuggested to protect it against

the inclemency of the weather

with

asnowmobile cover.

• Do not lubricate throttle

and/or

brake cables and housings.

• Only perform procedures as detailed

in this manual. Unless otherwise

specified, engine should be turned

OFF for all lubrication and mainte-

nance procedures.

• Since engine cooling is fully in ef-

fect only when the vehicle is in mo-

tion and driven on snow, it is not

recommended that you allow the

engine to idle for more than brief

periods

and/or

you drive the vehicle

on icy surface. Prolonged idling

and/

or continuous driving on ice may

cause engine damage.

• When removing coolant tank cap,

first place a cloth over cap then turn

cap to its first step to release pres-

sure. Never drain or refill the cooling

system when engine is hot.

• This vehicle is designed for the

driver only. No provisions have been

made for a passenger.

• PLEASEREAD AND UNDERSTAND

ALL WARNINGS AND CAUTIONS

IN THIS

MANUAL

AND ON THE

VEHICLE.

THIS

MANUAL

SHOULD

REMAIN

WITH

THE VEHICLE

THE

TIME

OF RESALE.

...

.16

....

.13

..........

'" .9

INDEX

THE 1982

"LIMITED

WARRANTY

OFTEN

ASKED

QUESTIONS

.. .

LISTING OF AREA

DISTRIBUTORS

HOW

IDENTIFY

YOUR

SNOWMOBILE

CONTROLS/INSTRUMENTS

Throttle lever, brake lever,

ignition/light

switch, high beam indicator, emergency

cut-out switch, headlarnp dimmer switch, rewind starter handle, primer, tachom-

eter, speedometer, temperature gauge, tether

cut-out

switch, oil level indicator,

fuel gauge, fuel tank cap, hood opening, adjustable steering handle, tool box .10

BREAK-IN PERIOD

Break-in, inspection, inspection checklist .

FUEL

Recommended gasoline, recommended injection oil 15

PRE·START

CHECK

Check

points.

...............................

.15

STARTING

PROCEDURE

Manual starting, emergency starting, before riding

LUBRICATION

Frequency, steering mechanism, chaincase oil level, rotary valve system, oil in-

jection system, drive axle, slide suspension . .17

MAINTENANCE

Chart, belt guard removal, drive belt removal, drive belt condition, brake condi-

tion, brake adjustment, spark plugs, suspension condition, suspension adjust-

ment, track condition, track tension and alignment, drive pulley, steering mecha-

nism, steering adjustment, muffler attachment, engine head nuts, engine mount

nuts, carburetor adjustment, oil injection pump adjustment, cooling system,

headlamp beam aiming, bulb replacement, general inspection '" 19

STORAGE

Cooling system, track, suspension, skis, controls, chaincase, fuel tank, carbure-

tor, cylinder lubrication, drive pulley, chassis, general

inspection.

. . . .

.27

PRE-SEASON PREPARATION

Pre-season preparation chart

...

LIMITED WARRANTY 1982 SKI·DOO® SNOWMOBILES

1·

PERIOD

BOMBARDIER® INC. as manufacturer, warrants FROM THE DATE OF FIRST

CONSUMER SALES, every 1982 SKI-DOO® snowmobile, sold as NEW

AND

UN-

USED, by an authorized SKI-DOO dealer, for periods of:

• 12 consecutive months

for

ELAN®,

CITATION*, EVEREST®, ELlTE®.

ALPINE® models.

• 90 consecutive days

for

NORDIK*,

SKANDIC*,

BLiZZARD® 5500

and 9500

models subject to the following:

1. If delivery is made after the 31st day

March

a given year and before the 1st

day of December

the same year, the above 90 day warranty will start on De-

cember 1st.

2. If delivery is made

on/or

after the 2nd day of January of a given year but before

the 31st day of March of the same year, all the unused portion

the 90 day pe-

riod will be carried over to the next winter and start again on the 1st day of De-

cember

the same year.

2·

WHAT

BOMBARDIER WILL DO

BOMBARDIER will repair

and/or

replace, at its option, components defective in

material

and/or

workmanship (under normal use and service.)

with

agenuine

BOMBARDIER component

without

charge

for

parts or labour, at any authorized

SKI-DOO dealer during said warranty period.

3·

CONDITION TO HAVE WARRANTY WORK PERFORMED

Present to the servicing dealer, the hard copy of the BOMBARDIER Customer Re-

gistration card received by the customer

from

the selling dealer at time

pur-

chase.

4-WARRANTY TRANSFER

This warranty is transferable to subsequent owner(s)

for

remainder of warranty pe-

riod from original date of sale.

5-EXCLUSIONS· ARE NOT WARRANTED

• Normal wear on all items such as, but

not

limited to:

- drive belts

- slider shoes

- spark plugs

- breaker points

- runners on skis

•Replacement parts

and/or

accessories which are

not

genuine BOMBARDIER

parts

and/or

accessories.

• Damage resulting

from

installation

parts other than genuine BOMBARDIER

parts.

• Damage caused by failure to provide proper maintenance as detailed in the

Operator Manual. The labour, parts and lubricants costs

all maintenance ser-

vices, including tune-ups and adjustments will be charged to the owner.

• A sulphated battery.

• Vehicles used for racing purposes.

• All optional accessories installed on the vehicle.

(The normal warranty policy

for

parts and accessories, if any, applies),

• Damage resulting

from

accident, fire or other casualty, misuse, abuse or ne-

glect.

• Damage resulting from modification to the snowmobile

not

approved in writing

by BOMBARDIER.

• Losses incurred by the snowmobile

owner

other than parts and labour, such as,

but not limited to, transportation,

towing,

telephone calls, taxis, or any other in-

cidental or consequential damages.

Some

states or provinces do

not

allow

the exclusion or limitation of inciden-

tal or consequential damages, so the above limitation or exclusion

may

not

apply.

6·

EXPRESSED OR IMPLIED WARRANTIES

This warranty gives you specific rights, and you

may

also have other legal

rights

which

may

vary

from

state to state, or province to province. Where ap-

plicable this warranty is expressly in lieu of all other expressed or implied

warranties

BOMBARDIER,

its distributors and the selling dealer, including

any warranty

merchantability

fitness for any particular purpose; other-

wise

the implied warranty is limited to the duration

this warranty.

How-

ever, some states or provinces do

not

allow

limitations on

how

long an im-

plied warranty lasts, so the above limitation

may

not

apply.

Neither the distributor, the selling dealer, nor any other person has been

authorized to

make

any affirmation, representation or warranty other than

those contained in this warranty, and if made, such affirmation, representa-

tion or warranty shall

not

be enforceable against

BOMBARDIER

or any other

person.

BOMBARDIER

INC.

reserves the right to modify its warranty policy

any

time, being understood

that

such modification

will

not

alter the warranty

conditions applicable

vehicles sold while the above warranty is in effect.

7·

CONSUMER ASSISTANCE

If a servicing problem or other difficulty occurs, we suggest the following:

1. Try to resolve the problem at the dealership

with

the Service Manager or

Owner.

2. If this fails, contact your area distributor listed in the Operator Manual.

3. Then if your grievance still remains unsolved, you may

write

to us:

Bombardier Inc.

Service Department

Recreational Products

Valcourt, Quebec, Canada, JOE 2LO

January 1981

Bombardier Inc.

Valcourt, Quebec, Canada, JOE 2LO

®'Trademarks of Bombardier Inc.

OFTEN ASKED QUESTIONS

Why

must my snowmobile be registered?

After

all I do have my original invoice

as proof of when I purchased my snowmobile.

Your warranty is valid

any

authorized dealer

the product. Your regis-

tration is the key element in providing the servicing dealer with the necessary

data to complete warranty claim forms. This information is also used to

notify

owners in the event

asafety recal/.

How

do I

know

my vehicle has been registered at the factory?

When you

bought

yoursnowmobite the dealer shouldhave completed,

and

iorwerded

us the manufacturer's copy

the Customer Warranty Registra-

tion. YOUR DEALER SHOULD HA VEGIVEN YOU THE

HARD

COpy

OF THE

WARRANTY

REGISTRA

nON

FORM.

Q: Ibought my snowmobile in O'King County but I snowmobile in Washington

County. Can the dealer in Washington County accept to perform warranty work

on my snowmobile?

Yes,

any

authorizeddealer in North America can perform warranty repairs,

providing the customer warranty registration card is presented.

Q: Where can I find information on the lubrication and maintenance of my snow-

mobile?

In this Operator Manual provided with the vehicle

the time

first sale.

Q: Will the entire warranty be void or cancelled, if 1do

not

operate or maintain my

new snowmobile exactly as specified in the Operator's Manual?

The warranty

the

new

snowmobile cannot be

"Voided"

"Cancelled",

However,

aparticular teiture is caused by operation

maintenance

other

than is shown in the OperatorManual, THA T failure may

not

be coveredunder

warranty. This includes service work

performed

by the customer, especially

the critical adjustments to ignition, timing, carburation

and

of!

injection/or

oil

mixture.

Q: Would you give some examples of abnormal use or strain, neglect or abuse?

These terms are general

and

overlap each

other

in areas. Some specific ex-

amples

may

include: running the machine

out

OIJ, chain teiture caused by a

lack

lubrication, operating the machine with abroken

damaged

part

which causes

another

part

to fail,

and

so on.

you have any specific questions

on operation

maintenance, please

contact

your dealer

for

advice.

What

costs are my responsibility during the warranty period?

The customer's responsibility includes

all

costs

normal

maintenance ser-

vices, non-warranty repairs, accidents

and

collision damage, as well as oils,

and

spark plugs,

and

incidental or consequential damages costs as explained

in the warranty.

Q: Are

"Genuine"

Bombardier replacement parts used in warranty repairs covered

by warranty?

Yes.

When installed by an authorized dealer, any

"genuine"

Bombardier

part

used in warranty repairs assumes the remaining

warranty

that

exists on

the machine.

I sell my snowmobile within the warranty period, will the

new

owner

qualify

for

the balance

the warranty?

Yes,

provided

the

unit

has already been registered with the manufacturer.

Note that the change

ownership card in this manual

should

be completed

and

sent to Bombardier Inc.

How

can I receive the best owner assistance?

The satisfaction

and

goodwill

the owners

Bombardierproducts are

primary concern to your dealer

and

Bombardier Inc. Normally,

any

problems

that arise in connection with the sales transaction

the operation

your

snowmobile will be handledby your Dealers Sales

Service Departments. It

is recognized, however,

that

despite the best intentions

everyone concern-

ed, misunderstandings

will

sometimes occur.

you have a problem that has

not

been handled to your satisfaction through normal channels, we suggest

that

you discuss yourproblem with amember

dealership management. Fre-

quently, complaints are the result

abreakdown in communications

and

can

quickly be resolved by a member

the dealership management.

the

prob-

lem already has been reviewed with the Sales Manager

Service Manager,

contact

the Dealer

himself

the General Manager.

LISTING OF AREA DISTRIBUTORS

CANADIAN DISTRIBUTORS

ALPINE DISTRIBUTORS LIMITED

Kalamalka Lake Road

P.O. Box 159

Vernon, British Columbia,

6M2

(604) 545-1314

British Columbia

BOMBARDIER INC.

EASTERN

CANADA

DISTRIBUTION

DIVISION

Atlantic Branch

P.O. Box 670

Shediac, New Brunswick,

EOA

3GO

(506) 532-4454

Magdalen Island, Nova Scotia, New

Brunswick, Prince Edward Island

BOMBARDIER INC.

EASTERN

CANADA

DISTRIBUTION

DIVISION

(Quebec Branch)

1350 Nobel Boulevard

Boucherville, Quebec, J4B 1A1

(514) 527-2469 or 655-6121

Province of Quebec

BOMBARDIER INC.

EASTERN

CANADA

DISTRIBUTION

DIVISION

Ontario Branch

230 Bayview Drive

Barrie, Ontario, L4M 2Y8

(705) 728-8600

Province of Ontario

BROOKS EQUIPMENT LIMITED

1616 King Edward Street

P.O. Box 985

Winnipeg, Manitoba, R3C 2V8

(204) 633-7247

Manitoba, Saskatchewan

HUDSON'S

BAY CO. LTD.

165 Hymus Blvd

Pointe-Claire, Quebec,

M4W

1A8

(514) 697-8500

North-West Territories, Franklin

District &Keewatin

J.W.

RANDALL

LIMITED

West Street

P.O.

Box 1050

Corner Brook, Newfoundland, A2H 6G7

(709) 634-3533

Newfoundland, Labrador

TRACT EQUIPMENT

14325, 114th Avenue

Edmonton, Alberta, T5M 2Y8

(403) 452-9910

Alberta, Dist. Mackenzie, Yukon,

N.W.T.

AMERICAN DISTRIBUTORS

BOMBARDIER CORPORATION

4505 West Superior Street

P.O. Box 6106

Duluth, Minnesota 55806

(218) 628-2881

North Dakota, Minnesota, Wisconsin,

Illinois, Missouri, Michigan, Indiana,

Ohio (less eastern half), Tennessee,

Kentucky, West Virginia, Virginia,

Northern Idaho, Northern Wyoming,

Montana, Iowa, Washington.

ELLIOTT &HUTCHINS INC.

East Main Street Road

Malone, New York 12953

(518) 483-4411

New York, Massachusetts, Connec-

ticut, Rhode Island, P,ennsylvania,

New

Jersey, Maryland, Delaware,

District of Columbia, Eastern half of

Ohio, Maine, New Hampshire, Vermont.

MILLER EQUIPMENT AND

RECREATIONAL CENTER

1049 Whitney Road

Anchorage, Alaska

99501

(907l 274-9513

Alaska

Inhaltsverzeichnis

Andere Ski-Doo Schneemobil Handbücher

Ski-Doo

Ski-Doo CK3 Series 2002 Handbuch

Ski-Doo

Ski-Doo REV Series Handbuch

Ski-Doo

Ski-Doo ALPINE VALMOMT Bedienungsanleitung

Ski-Doo

Ski-Doo MX Z 440 Installationsanleitung

Ski-Doo

Ski-Doo MXZ X 600 RS 2021 Bedienungsanleitung

Ski-Doo

Ski-Doo Grand Touring 500 1998 Installationsanleitung

Ski-Doo

Ski-Doo Grand Touring 700/SE Installationsanleitung

Ski-Doo

Ski-Doo MX Z 800 2145 2002 Handbuch

Ski-Doo

Ski-Doo REV-XR 2009 Handbuch

Ski-Doo

Ski-Doo REV GEN4 Handbuch

Ski-Doo

Ski-Doo NORDIK 50 1988 Bedienungsanleitung

Ski-Doo

Ski-Doo REV Series Installationsanleitung

Ski-Doo

Ski-Doo 850 Silber Bedienungsanleitung

Ski-Doo

Ski-Doo Tundra R Skandic LT 2003 Betriebsanleitung

Ski-Doo

Ski-Doo Safari 1990 Bedienungsanleitung

Ski-Doo

Ski-Doo 2000 MX Zx 440 LC Handbuch

Ski-Doo

Ski-Doo Alpine II 1990 Bedienungsanleitung

Ski-Doo

Ski-Doo MX Bedienungsanleitung

Ski-Doo

Ski-Doo REV G4 Trail/Crossover E-TEC Series Handbuch

Ski-Doo

Ski-Doo REV series 2007 Bedienungsanleitung

Ski-Doo

Ski-Doo 861 002 700 Bedienungsanleitung

Ski-Doo

Ski-Doo CK3 Series Handbuch

Ski-Doo

Ski-Doo Alpine 1985 Bedienungsanleitung

Ski-Doo

Ski-Doo SKANDIC EXPEDITION 600 H.O. SDI 2005 Handbuch

Beliebte Schneemobil Handbücher anderer Marken

BRP

BRP Ski-Doo MXZ 120 2023 Bedienungsanleitung

Arctic Cat

Arctic Cat ZR 900 Series 2006 Bedienungsanleitung

Arctic Cat

Arctic Cat Wildcat EFI Mountain Cat 1994 Bedienungsanleitung

BOMBARDIER

BOMBARDIER Ski-Doo Alpine 74 1959 Bedienungsanleitung

Arctic Cat

Arctic Cat Cougar Bedienungsanleitung

Yamaha

Yamaha SnoScoot SXR2NJ Bedienungsanleitung

Yamaha

Yamaha VX500XTB Bedienungsanleitung

Yamaha

Yamaha RS VENTURE 2014 Bedienungsanleitung

Polaris

Polaris RMK Shift Bedienungsanleitung

Yamaha

Yamaha VK540EF Bedienungsanleitung

Yamaha

Yamaha VK540EF Bedienungsanleitung

BOMBARDIER

BOMBARDIER ski-doo Nordic 640ER 1974 Bedienungsanleitung

BOMBARDIER

BOMBARDIER ski-doo OLYMPIQUE 300 1974 Bedienungsanleitung

Yamaha

Yamaha SXV4NP Bedienungsanleitung

Ohlins

Ohlins PB 616 Bedienungsanleitung

Polaris

Polaris 600 RUSH 2013 Leitfaden

BOMBARDIER

BOMBARDIER Ski-doo MX ZX 440 Handbuch

Polaris

Polaris 600 INDY VOYAGEUR Bedienungsanleitung