Ski-Doo 2000 MX Zx 440 LC Handbuch

Printed in Canada (MMO2000-005BACKcover_A.fm GM)

®*Trademarks of Bombardier Inc. and/or its subsidiaries.

SAFETY WARNING

Disregarding any of the safety precautions and instructions con-

tained in this

Operator’s Guide Supplement

Safety Handbook

on-product labels could cause injury, including the possibility of

death.

This

Operator’s Guide

handbook should remain with the snowmo-

bile at all time.

BOMBARDIER

Recreational Products

After Sales Service

Sherbrooke (Quebec)

Canada J1L 1W3

MMO2000-005BACKcover_A.fm Page 1 Tuesday, September 28, 1999 1:58 PM

Dear 2000 MX Zx 440 LC owner, all informations on

MX Z 600 in the

2000 ZX Series Operator's Guide

(P/N

484 100 017) also applies to your MX Zx 440 LC except

for the following.

LIMITED WARRANTY VALIDATION

The 2000 MX Zx 440 LC is shipped from the factory with high com-

pression ratio (CR) combustion chamber inserts installed.

To validate limited warranty coverage, low CR combustion chamber

inserts must be installed on engine.

CONTROLS/INSTRUMENTS

NOTE: See description or numbered items in





(P/N 484 100 017) except for the following.

A32A0DA

26 26

1120 181032 9

23-24

MMO2000-005_A.fm Page 1 Tuesday, September 28, 1999 1:47 PM

7) Tether Cut-Out Switch

Attach tether cord to clothing then snap tether cut-out cap over re-

ceptacle before starting engine.

To stop engine, completely pull cap from safety switch.

28) Primer Button

Pull and push button. It is not necessary when engine is warm.

To prime, activate button until a pumping resistance is felt. From this

point, pump 2 or 3 times to inject fuel in intake manifold. After prim-

ing, ensure that primer button is pushed back.

NOTE: In very cold temperature, it is recommended to rotate primer

button 3-4 turns prior to pull it. This will eliminate the possibility of

sticking.

29) Adjustable Toeholds

Each toehold can be adjusted to suit driver's preference. Loosen

bolts, adjust then, retighten bolts to 10 N•m (89 lbf•in).

RIGHT SIDE SHOWN

1. Toehold

2. After adjustment retighten bolts to 10 N•m (89 lbf•in)

A32H0VA

MMO2000-005_A.fm Page 2 Tuesday, September 28, 1999 1:47 PM

FUEL AND OIL

Recommended Fuel

Use super unleaded gasoline, available from most service stations or

gasohol containing less than 10% of ethanol or methanol. The gaso-

line used must have an octane number (R + M)/2 of 91 or higher.

NOTE: In most service station pump octane number corresponds to

(R + M)/2 octane number.

When snowmobile is used in powder snow condition and/or at tem-

peratures from and below - 10°C (14°F), we highly recommend the

use of gas line antifreeze in a proportion of 150 mL (5 U.S. oz) of gas

line antifreeze added to 40 liters (10-1/2 U.S. gal) of gas.

This precaution is in order to reduce the risk of frozen carburetor(s)

which may lead, in certain cases, to high fuel consumption or severe

damage to engine.

NOTE: Use only methyl hydrate free gas line antifreeze, Kleen-

Flo™ or equivalent.

CAUTION: Never experiment with other fuels or fuel ratios. The

use of unrecommended fuel can result in snowmobile perfor-

mance deterioration and damage to critical parts in the fuel sys-

tem and engine components.

Recommended Oil

CAUTION: Never mix brands of 2-cycle oil as chemical reaction

can cause engine damage. Never use outboard or straight min-

eral oils. Use only oil that flows at - 40°C (- 40°F).

Use BOMBARDIER-ROTAX injection oil (P/N 413 802 900 — 12 x 1 L)

available from authorized dealer or suitable equivalent. This type of

oil will flow at temperatures as low as minus 40°C (- 40°F).

WARNING

Never top up the fuel tank before placing the snowmobile in a

warm area. As temperature increases, fuel expands and might

overflow. Fuel is flammable and explosive under certain con-

ditions. Always wipe off any fuel or oil spillage from the snow-

mobile.

MMO2000-005_A.fm Page 3 Tuesday, September 28, 1999 1:47 PM

OIL/FUEL 33/1

METRIC (SI)

1 L of oil + 33 L of fuel = 33/1

IMPERIAL

35 imp. oz of oil + 7.2 imp. gal of fuel = 33/1

1 L of oil + 7.2 imp. gal of fuel = 33/1

UNITED STATES

34 U.S. oz of oil + 8.8 U.S. gal of fuel = 33/1

1 L of oil + 8.8 U.S. of fuel = 33/1

A32I09A

MMO2000-005_A.fm Page 4 Tuesday, September 28, 1999 1:47 PM

STARTING PROCEDURE

• Re-check throttle control lever operation.

• Ensure that the emergency cut-out switch is in the ON position.

• Ensure the tether cut-out cap is in position and that the cord is

attached to your clothing.

• To prime, activate button until a pumping resistance is felt. From

this point, pump 2 or 3 times to inject fuel in intake manifold. After

priming, ensure that primer button is pushed back.

NOTE: In very cold temperature, it is recommended to rotate primer

button 3-4 turns prior to pull it. This will eliminate the possibility of

sticking.

NOTE: Priming is not necessary when engine is warm.

MMO2000-005_A.fm Page 5 Tuesday, September 28, 1999 1:47 PM

FLUID LEVEL

Coolant Pump Shaft Oil Reservoir

Use BOMBARDIER-ROTAX injection oil (P/N 413 802 900) (12 x 1 L).

Fill up to mark.

Coolant Reservoir

Use ethylene-glycol antifreeze for aluminum engines mixed with wa-

ter (3 parts of antifreeze for 2 parts of water).

Fill up to mark when engine is cold.

1. Coolant pump shaft oil filling mark

2. Coolant cold level mark

A32C10A

MMO2000-005_A.fm Page 6 Tuesday, September 28, 1999 1:47 PM

MAINTENANCE

Track Tension and Alignment

Loosen lock nut on both adjustment screws before adjusting track

tension and/or alignment. Retighten after adjustments are done.

LEFT SIDE SHOWN

1. Lock nut on adjustment screw

A32F0WA

MMO2000-005_A.fm Page 7 Tuesday, September 28, 1999 1:47 PM

SPECIFICATIONS



Measure gap between slider shoe and bottom inside of track when

exerting a downward pull of 7.3 kg (16 lb) to the track.



Equal distance between edges of track guides and slider shoes.



Super unleaded gasoline with a minimum octane number of 91

(R + M)/2.



BOMBARDIER-ROTAX injection oil (P/N 413 809 900) (12 x 1 L).



Bombardier synthetic chaincase oil (P/N 413 803 300).



Ethylene-glycol antifreeze for aluminum engines mixed with water

(3 parts of antifreeze for 2 parts of water).

Bombardier reserves the right at any time to discontinue or change

specifications, designs features, models, prices or equipment with-

out incurring obligation.

GENERAL MX Zx 440 LC

Engine

– Maximum power engine speed ± 50 RPM 8450

Drive belt

– Number 414 860 700

– New belt width mm (in) 34.9 (1-3/8)

– Wear limit width mm (in) 32.5 (1-1/4)

Spark plug

– Type NGK BR 9 ES

– Gap mm (in) 0.45 (.018)

Track

– Tension mm (in) 30 to 35 (1-3/16 to 1-3/8)



– Alignment



FLUIDS

Fuel

–Type



– Tank capacity L (U.S. gal) 37 (9.86)

Oil (engine)

–Type



– Premix ratio 33/1

Chaincase/Transmission Oil

–Type



– Capacity mL (U.S. oz) 250 (8.5)

Cooling System

–Type



– Capacity L (U.S. oz) 3.5 (118)

Brake System Fluid

– Type DOT 4

MMO2000-005_A.fm Page 8 Tuesday, September 28, 1999 1:47 PM

Inhaltsverzeichnis

Andere Ski-Doo Schneemobil Handbücher

Ski-Doo

Ski-Doo MXZ X 600 RS 2021 Bedienungsanleitung

Ski-Doo

Ski-Doo EXPEDITION V-1000 Bedienungsanleitung

Ski-Doo

Ski-Doo Alpine II 1990 Bedienungsanleitung

Ski-Doo

Ski-Doo OLYMPIQUE 300 Bedienungsanleitung

Ski-Doo

Ski-Doo Blizzard 7500 Bedienungsanleitung

Ski-Doo

Ski-Doo Grand Touring 700/SE Installationsanleitung

Ski-Doo

Ski-Doo CK3 Series 2002 Handbuch

Ski-Doo

Ski-Doo Skandic WT 2013 Handbuch

Ski-Doo

Ski-Doo Tundra R Skandic LT 2003 Betriebsanleitung

Ski-Doo

Ski-Doo Grand Touring 500 1998 Installationsanleitung

Ski-Doo

Ski-Doo 1982 Elite Bedienungsanleitung

Ski-Doo

Ski-Doo Tundra II LT 1998 Installationsanleitung

Ski-Doo

Ski-Doo REV Series Handbuch

Ski-Doo

Ski-Doo Tundra II LT 1997 Installationsanleitung

Ski-Doo

Ski-Doo MX Z 800 2145 2002 Handbuch

Ski-Doo

Ski-Doo ALPINE VALMOMT Bedienungsanleitung

Ski-Doo

Ski-Doo REV Series Installationsanleitung

Ski-Doo

Ski-Doo Legend 800 2002 Bedienungsanleitung

Ski-Doo

Ski-Doo REV XP 2008 Series Handbuch

Ski-Doo

Ski-Doo 1982 Blizzard 5500 MX Bedienungsanleitung

Ski-Doo

Ski-Doo Formula Plus 1985 Bedienungsanleitung

Ski-Doo

Ski-Doo NORDIK 50 1988 Bedienungsanleitung

Ski-Doo

Ski-Doo 1997 Tundra II LT 3266 Bedienungsanleitung

Ski-Doo

Ski-Doo Alpine 1985 Bedienungsanleitung

Beliebte Schneemobil Handbücher anderer Marken

BRP

BRP Ski-Doo MXZ 120 2023 Bedienungsanleitung

Arctic Cat

Arctic Cat ZR 900 Series 2006 Bedienungsanleitung

Arctic Cat

Arctic Cat Wildcat EFI Mountain Cat 1994 Bedienungsanleitung

BOMBARDIER

BOMBARDIER Ski-Doo Alpine 74 1959 Bedienungsanleitung

Arctic Cat

Arctic Cat Cougar Bedienungsanleitung

Yamaha

Yamaha SnoScoot SXR2NJ Bedienungsanleitung

Yamaha

Yamaha VX500XTB Bedienungsanleitung

Yamaha

Yamaha RS VENTURE 2014 Bedienungsanleitung

Polaris

Polaris RMK Shift Bedienungsanleitung

Yamaha

Yamaha VK540EF Bedienungsanleitung

Yamaha

Yamaha VK540EF Bedienungsanleitung

BOMBARDIER

BOMBARDIER ski-doo Nordic 640ER 1974 Bedienungsanleitung

BOMBARDIER

BOMBARDIER ski-doo OLYMPIQUE 300 1974 Bedienungsanleitung

Yamaha

Yamaha SXV4NP Bedienungsanleitung

Ohlins

Ohlins PB 616 Bedienungsanleitung

Polaris

Polaris 600 RUSH 2013 Leitfaden

BOMBARDIER

BOMBARDIER Ski-doo MX ZX 440 Handbuch

Polaris

Polaris 600 INDY VOYAGEUR Bedienungsanleitung