Town & Country Fireplaces TC30.NG02CN Bedienungsanleitung

TC30

COUNTRY HOME

BURNER KIT

INSTRUCTIONS

(NATURAL GAS ONLY)

PART#

TC30.NG02CN

For TC30 Series C

130411-12 TC30.NG02CN 5056.42902

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

These instructions are supplementary to the Installation and

Operating Instructions supplied with the replace and should be

kept together. Refer to the Installation and Operating Instructions

for proper gas supply, safety requirements and operating

instructions

TC30.NG02CN 130411-12

Contents of Package

Burner/Grate Installation

BURNER ASSEMBLY

7 PCS LOG SET

HARDWARE PACKAGE

EMBER MATERIAL

LOG GRATE

1. Place the keyhole slots in the burner

over the two screws located in the rebox

base. (Fig. #1 & 1a)

2. Slide the burner back to engage the

screws in the small part of the keyhole

slot and tighten screws. (Fig. #1b)

3. Remove access cover from side of

rebox(Fig. #1c)

Fig. # 1a

Fig. # 1b

SCREWS

Fig. # 1

Fig. # 1c

TC30.NG02CN 130411-12

BULKHEAD PLATE

2 SCREWS

4. Secure the electrical bulkhead plate and

gasket to the rebox.(2 screws) Attach the

ignition and sensor wires to the module.

Red end to the connector marked by the

red dot, white end to the connector marked

by the white dot

Fig.#2 & Fig.#3

Fig. # 2

Burner/ Grate Installation

RED END TO

RED DOT

WHITE END TO

WHITE DOT MODULE

Fig. # 3

TC30.NG02CN 130411-12

PILOT SUPPLY

TUBE

MAIN GAS SUPPLY

TUBE

Fig. # 4

5. Attach the pilot and gas supply tubes to

the bulk head tting and tighten.

(Fig. # 3b) Ensure the connections are

gas tight. Conceal the spark and

sensor wires below the supply tubes.

A panel set must now be installed. See

Installation and Operating Instructions

manual for details.

6. Position the slots of the grate securing

brackets over the holes in the oor shield

and secure with the two screws

(Fig. # 4).

Fig. # 3b

TC30.NG02CN 130411-12

Fig. # 5

AIR DEFLECTOR

SECURING

SCREWS

Ember Material Placement

A large bag of ember material is shipped with

the replace and needs to be installed to ensure

optimum performance and ame appearance.

Pull apart the material into ember size pieces

(approximately 1” squares) and gently place them

into the burner pan.Do not compress, leave it loose

for best performance.

Fill the burner pan level with the top of the pan at

rear, and gradually slope forward to the rebox oor

at the front, covering both burner tubes.

Place remaining ember material outside of the

burner pan as desired to cover-up gas lines and

brackets.

Note: Ember material placement and amount will

affect ame appearance. More ember material

results in lower ame height. Add or remove as

needed until desired ame affect.

Fig. # 5b

GLOWING EMBERS

7. Attach rear deector to rear of grate

using the two screws provided

(Fig. # 5).

TC30.NG02CN 130411-12

Gas plumbing and vent connections

should be completed before proceeding.

The logs are fragile, and should be handled

with care. Unpack and inspect log set.There

should be a total of seven logs.

Position the logs as indicated by the following

pictures.The three main logs have holes and

/ or pins. Engage each pin in the correspond-

ing holes. The four smaller logs do not have

holes or pins.They rest in position. Locate as

per the diagrams (g. # 6-13).

Log Placement

Fig #6

Fig #7

TC30.NG02CN 130411-12

Fig #8

Fig #9

TC30.NG02CN 130411-12

Fig #10

Fig #11

TC30.NG02CN 130411-12

Fig #12

Fig #13

Note:

Improper placement of logs will

cause sooting on internal parts

and glass. The logs may need to

be repositioned slightly to avoid

excessive ame impingement. 4

TC30.NG02CN 130411-12

1. Remove the blanking plug from the

pressure test port. The plug is located

between the right side lintel and

rebox side. (Fig. #14)

2. Thread the extension test tting into the

open test port. (Fig. #15)

3. Attach a pressure gauge onto the

tting.

4. When testing is complete remove the

extension test tting and replace the

plug. Thread sealant will be required to

ensure a gas tight connection.

Correct gas pressure requirement:

Supply Pressure Natural Gas

Min. Pressure 5.0" WC

(For purpose of input adjustment)

Max. Pressure 13.9" WC

Manifold Pressure

Maximum 3.8" WC

Minimum 2.1" WC

SUPPLY

PRESSURE

MANIFOLD

PRESSURE

Fig #16

Note:To test the gas pressure,turn off the

gas supply before removing the blanking

plug from the supply pressure test port

or manifold pressure test port.

Verify gas pressures with the replace

lit and on the highest setting.

Gas Pressure Check

Fig #14

Fig #15

Inhaltsverzeichnis

Andere Town & Country Fireplaces Kamin im Innenbereich Handbücher

Town & Country Fireplaces

Town & Country Fireplaces TC36 SEE-THRUC SERIES Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54ST SERIES D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS38 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCVT.WSPVB1 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36ST Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC54 SERIES DMODULAR Gebrauchsanweisung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54 SERIES D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54NG04.C2 Technisches Handbuch

Town & Country Fireplaces

Town & Country Fireplaces Series C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30.NG04D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS38 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42.NG01 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC54.CE2 Series C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 AR Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.OD Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30.CE3 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54STOK Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30D2 Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch