Town & Country Fireplaces TC30.NG04D Bedienungsanleitung

TC30

TRANQUILITY

BURNER KIT

INSTRUCTIONS

PART#

TC30.NG04D

For TC30 Series D

Fireplaces

270315-16 TC30_NG04D 5056.42904D

These instructions are supplementary to the Installation

and Operating Instructions supplied with the replace

and should be kept together. Refer to the Installation

and Operating Instructions for proper gas supply, safety

requirements and operating instructions.

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

TC30_ng04D_270315-16

5056.42904D

If converting to propane see conversion instructions on page #6

before proceeding.

NOTE: Plug the 4 vacant holes in the bottom of the rebox with 1/2” screws,

as they are not required to attach this style of burner.

1. Bend ex lines into the approximate shape. (Fig #1)

2. Place covers under the burner tray. (Fig #2 & 3)

NOTE: Shutter must be fully closed for Natural gas, half open for Propane.

1 BURNER ASSEMBLY

1 PANEL, BASE

1 PEBBLE ASSEMBLY

2.2 LBS. SAND

1 COVER RHS

1 COVER LHS

1 BAG TAPERED PLUGS (NOT SHOWN)

Fig #3

Fig #1 Fig #2

Contents of Package

Tranquility Burner Installation

TC30_ng04D_270315-16 5056.42904D

3. Position lower rear porcelain panel

centered at the rear of the rebox. Place

burner assembly into the rebox against

the rear panel.

(Fig #4)

4. Attach the manifold supply tube and

the pilot supply tube to the bulk head

ttings and tighten. (Fig. #5) Ensure

that there are no leaks.

Fig #4

Fig #5

TC30_ng04D_270315-16

5056.42904D

BULKHEAD PLATE

2 SCREWS

Fig #6

Fig #7

INTERFACE

MODULE

IGNITION

WIRE

(RED)

FLAME

SENSOR

WIRE

(WHITE)

4. Secure the electrical bulkhead plate

(Fig.#6) and gasket to the rebox. (2

screws) Attach the ignition and sensor

wires to the module. (Fig.#7)

TC30_ng04D_270315-16 5056.42904D

6. Remove panel retainer clips from upper

heat shield. Install right porcelain panel

tilting in from front corner. Secure the

right panel with one of the previously

removed panel retainer clips. (Fig #8)

7. Bend up retaining clip on the left panel.

Position upper rear panel on the top of

the lower rear panel and behind the right

panel. While supporting the upper rear

panel install and secure the left panel in

the same manner as the right panel.

(Fig #9)

Fig #8

Fig #9

TC30_ng04D_270315-16

5056.42904D

8. Bend the retaining clip down over the

upper back panel.

(Fig #10)

NOTE:The clips can be adjusted side

to side to minimize any gaps between

the panels.

9. Slide covers out and attach to base with

one screw each.

(Fig #11)

Fig #10

Fig #11

TC30_ng04D_270315-16 5056.42904D

10. Insert tapered plugs into raised burner

ports to prevent sand from entering ports.

(Fig #12)

11. Place sand in tray. Brush sand smooth

and level to just below top of raised

burner ports. Gently blow excess sand

from around ports.

(Fig #13)

12. Remove tapered plugs from ports.

Fig #12

Fig #13

TC30_ng04D_270315-16

5056.42904D

Fig #14

Fig #15

13. Remove pebble assembly from

packaging by placing hand on top and

tipping upside down. Gently place

pebble assembly onto sand base

using pins to locate position.

(Fig #14)

NOTE:

Lift pebble assembly from bottom.

Do not lift by top rocks.

Hollowed out rock must cover the

pilot.

14. Install glass door. Unit is ready for

lighting.

TC30_ng04D_270315-16 5056.42904D

WARNING

This conversion kit

shall be installed by a

qualied service agency

in accordance with the

manufacturer's instructions

and all applicable codes

and requirements of

the authority having

jurisdiction.

If the information in these

instructions is not followed

exactly, a re, explosion

or production of carbon

monoxide may result

causing property damage,

personal injury or loss of

life.

The qualied service

agency is responsible for

the proper installation of

this kit.

The installation is not

proper and complete

until the operation of the

converted appliance is

checked as specied in the

manufacturer's instructions

supplied with the kit.

If the unit is to be used on propane

convert as follows using the

components supplied with this

burner:

CAUTION

The gas supply and electrical power

shall be shut off before proceeding

with the conversion.

Note:

Factory supplied components must

be used to ensure correct input. After

conversion confirm proper manifold

pressure.

1. Remove the 2 front screws holding the

burner tray in place.

(Fig. #16)

2. Gently lift up the burner tray while

sliding to the left to disengage the

burner tube from the orice. Then tip

back to expose the orice.

3. Using a 1/2” wrench, undo the

natural gas burner orice,

(marked #32). Apply a small amount

of pipe joint compound to the threads

of the propane burner orice

(marked #48) to ensure a good seal,

before screwing it into the tting.

Loosen the primary air shutter screw,

open shutter half way and re-tighten.

(Fig. #17)

4. Remove the 2 screws holding the

pilot assembly in place with a stubby

screwdriver.

(Fig #18)

The burner assembly must

be removed from the unit if

previously installed.

Fig #16

Fig #17

Fig #18

Propane Conversion

MAIN BURNER (1.90 mm)

ORIFICE (5022.76)

TC30_ng04D_270315-16

5056.42904D

5. With a 7/16”wrench loosen the pilot head

on the pilot assembly using a wrench to

hold the bracket steady. (Fig. #19)

6. Slide the pilot adjustment band over and

ensure that the hole in the orice band

is showing.

Fig. #20a shows NG position

Fig #19

Fig #20a

Andere Handbücher für TC30.NG04D

Inhaltsverzeichnis

Andere Town & Country Fireplaces Kamin im Innenbereich Handbücher

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54CE3 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 SEE-THRUC SERIES Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36ST Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC54.NG03C2 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS38 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS38 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54STOK Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36ST Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54CODE Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54CE SERIES C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces Architectural Series Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54DST Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces D Series Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces Model TC42SeriesC Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36D2 ARCH Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces D2 Series Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54ST SERIES D Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch