Town & Country Fireplaces TC36.NG03D Bedienungsanleitung

PART #TC36.NG03D

For TC36 & TC36 Arch

Series D Fireplaces

TC36

BLACK DIAMOND

BURNER KIT

INSTRUCTIONS

091014-20 TC36_NG03D 5056.427D3

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

These instructions are supplementary to the Installation and

Operating Instructions supplied with the replace and should be

kept together. Refer to the Installation and Operating Instructions

for proper gas supply, safety requirements and operating

instructions

TC36_NG03D 091014-20

• BURNERTUBE

• MEDIASPACER,Rear

• BURNERTRAYASSY

• MEDIASPACER,Front

• 5lbs.TUMBLEDGLASS

• MEDIASPACER,Center

• BURNERSHIELD

• PANEL,LOWERREAR

• MANIFOLDASSEMBLY

(including supply tube)

• PILOTSHIELD

(including pilot and supply tube)

• HARDWAREPACKAGE

NOTE:MUSTBEUSEDWITHPORCELAINPANELSETPART#TCPN.757031.C

A porcelain panel set must be used in conjunction with

the installation of the burner assembly.

1) Remove 2 screws from the air channel and attach the lower

rearpaneltothereboxwiththesescrews.(Fig.#1)

NOTE: The burner shield may need to be loosened and

re-tightned after positioning if the panel does not slip in

behind it.

Fig. # 1

Package Contents

Burner Installation

TC36_NG03D 091014-20

2) Attachthemanifoldbrackettotheoor

shield in the bottom of the rebox with

onescrew.(Fig.#2)

3) Attachthemanifoldandpilotsupply

tubes to the bulk head tting and

tighten.(Fig.#3)Ensurethatall

connections are gas tight.

Fig. # 3

Fig. # 2

TC36_NG03D 091014-20

Fig. # 4

BULKHEAD PLATE

2 SCREWS

4. Securetheelectricalbulkheadplate

(Fig.#4) and gasket to the rebox. (2

screws)Attach the ignition and sensor

wirestothemodule.(Fig.#5).)

NOTE: If converting to propane refer to

the propane conversion section

before continuing. Pg. 12

INTERFACE

MODULE

IGNITION

WIRE

(RED)

FLAME

SENSOR

WIRE

(WHITE)

Fig. # 5

TC36_NG03D 091014-20

Fig. # 6

5) Remove panel retainer from the upper

heat shield. Install right side panel by

placing the bottom into the rebox and

tipping the top into position.

 (Fig.#6)

6) Position upper rear panel on top of

lower rear panel and slip in behind

therightpanel.(Fig.#7)

Fig. # 7

TC36_NG03D 091014-20

Fig. # 8

7) Whilesupportingtheupperrearpanel

install the left side panel in the same

mannerastherightsidepanel.Secure

both side panels with the previously

removedpanelretainer.(Fig.#8)

8) Install burner shield by tipping the

shield into the rebox, feed the pilot

assembly through the opening in the

shield.(Fig.#9)

Fig. # 9

TC36_NG03D 091014-20

Fig. # 10

Fig. # 11

9) With a short,stubbyscrewdriver,

attach pilot shield to burner tray with

two screws.

 (Fig.#10)

10)Attachtheburnertraytotheburner

shield using two screws at the back

ofthetray.(Fig.#11 ) Ensurethatfront

mounting holes are aligned inder tray

before tightening.

TC36_NG03D 091014-20

Fig. # 12

Fig. # 13

11) Install front and rear media spacers.

(Fig.#12&13)

TC36_NG03D 091014-20

12) Install burner by tilting burner tube

throughthetray.Ensurethattheorice

has entered the tube.

 (Fig.#14&15)

Set the air shutter to fully open for

Propane or fully closed for Natural

gas.

Fig. # 14

Fig. # 15

ORIFICE INLET TUBE

TC36_NG03D 091014-20

13)Installthecentermediaspacer.Se-

cure the spacer and burner with two

longscrews.(Fig. # 16)Fourholes

mustlineuptoseteachscrew.Some

pressure may need to be applied to

the front tray support on the shield to

aligntheholes.(Fig.#17)

Fig. # 16

Fig. # 17

Andere Handbücher für TC36.NG03D

Inhaltsverzeichnis

Andere Town & Country Fireplaces Kamin im Innenbereich Handbücher

Town & Country Fireplaces

Town & Country Fireplaces TCW120 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces Architectural Corner Right Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30.NG05D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36AR Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS38 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC54 SERIES DMODULAR Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54ST SERIES D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54ST SERIES D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC54 SERIES DMODULAR Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54ST SERIES D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54ST SERIES D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30.CE3 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces Series C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS38 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 SEE-THRUC SERIES Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS38 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces Series C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch