Weslo 831.291030 Bedienungsanleitung

Model No. 831.291030

Serial No.

Serial Number Decal

CAUTION

Read all precautions and instruc-

tions in this manual before using

this equipment. Save this manual

for future reference.

• Assembly

• Operation

• Maintenance

• Part List and Drawing

TREADMILL EXERCISER

User’s Manual

Sears, Roebuck and Co., Hoffman Estates, IL 60179

TABLE OF CONTENTS

IMPORTANT PRECAUTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

BEFORE YOU BEGIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

TREADMILL OPERATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

MAINTENANCE AND TROUBLESHOOTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

CONDITIONING GUIDELINES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

PART LIST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

EXPLODED DRAWING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

ORDERING REPLACEMENT PARTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Back Cover

FULL 90 DAY WARRANTY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Back Cover

IMPORTANT PRECAUTIONS

WARNING: To reduce the risk of serious injury, read the following important precau-

tions before using the treadmill.

1. It is the responsibility of the owner to ensure

that all users of the treadmill are adequately

informed of all warnings and precautions.

2. Use the treadmill only as described.

3. This treadmill is intended for in-home use

only. Do not use the treadmill in a commer-

cial, rental, or institutional setting.

4. Place the treadmill on a level surface, with

eight feet of clearance behind it. Place a mat

under the treadmill to protect the floor.

5. Inspect and properly tighten all parts of the

treadmill regularly; replace any worn parts

immediately.

6. The roller guards must be 1/8 inch from the

rear roller (see the drawing on page 3). Adjust

the roller guards, if necessary.

7. Keep children under the age of 12 and pets

away from the treadmill at all times.

8. The treadmill should not be used by persons

weighing over 250 pounds. Never allow more

than one person on the treadmill at a time.

9. Wear appropriate clothing when exercising.

Do not wear loose clothing that could become

caught on the treadmill.

10.Always wear athletic shoes when using the

treadmill; do not use the treadmill with bare

feet, wearing only stockings, or in sandals.

11. Do not use the treadmill if it is not working

properly.

12.Do not place hands or feet under the treadmill

while it is in use.

13.Always hold the handrail when mounting,

dismounting, or exercising on the treadmill.

14.If you feel pain or dizziness while exercising,

stop immediately and begin cooling down.

15.The decal shown below has been placed on

the treadmill in the location shown on page 3.

If the decal is missing or illegible, call toll-free

1-800-999-3756 and order a free replacement

decal. Apply the decal in the location shown.

WARNING: Before beginning this or any exercise program, consult your physician. This

is especially important for persons over the age of 35 or persons with pre-existing health problems.

Read all instructions before using this product. Sears assumes no responsibility for personal injury

or property damage sustained by or through the use of this product.

Handrail

Console

Hood

Walking Belt

Rear Roller Adjustment Bolts

Roller Guards

BEFORE YOU BEGIN

Thank you for selecting the new WESLO®SMOOTH-

STRIDER treadmill. The SMOOTHSTRIDER treadmill

is designed to let you enjoy effective cardiovascular

workouts in the comfort and convenience of your

home. And when the SMOOTHSTRIDER treadmill is

not in use, it can be folded up, requiring less than half

the space of other treadmills.

For your benefit, read this manual carefully before

using the treadmill. If you have questions after read-

ing this manual, call 1-800-4-MY-HOME®(1-800-469-

4663).To help us assist you, please note the product

model number and serial number before calling. The

model number of the treadmill is 831.291030. The seri-

al number can be found on a decal attached to the

treadmill (see the front cover of this manual for the

location).

Before reading further, please review the drawing

below and familiarize yourself with the labeled parts.

Warning Decal

ASSEMBLY

The help of a second person is recommended. Set the treadmill in a cleared area and remove all packing

materials. Do not dispose of the packing materials until assembly is completed. Assembly requires only the

included allen wrench and wrench .

Hole

Holes

1. Identify the Right Upright (36), which has a single hole in

the indicated location. Hold the Right Upright against the

Base (14) as shown, and orient the Right Upright so the

two indicated holes are on the side shown.

Attach the Right Upright (36) to the Base (14) with two

M8 x 50mm Bolts (38), two M8 Curved Washers (37),

and two M8 Nylon Nuts (13) as shown.

Attach the Left Upright (35) to the Base (14) in the same

way. Make sure that the Left Upright is oriented so the

two indicated holes are on the side shown.

3. Attach the Hood (28) to the front of the Frame (29) with

two M5 x 10mm Bolts (10). 3

2. Raise the Left Upright (35) and the Right Upright (36) to

the position shown. Feed the Reed Switch Wire (6) into

the top of the Left Upright and out of the indicated hole.

Hole

35 36

4. See drawing 4a. Hold the front of the Frame (29)

between the Left Upright (35) and the Right Upright (not

shown). Align the holes near the front of the Frame with

one of the three sets of adjustment holes in the Uprights.

Insert a Pin (4) into each Upright and each side of the

Frame. Make sure that the Pins are fully inserted at

the same height.

Look under the Frame (29) near the Left Upright (35).

See drawing 4b. Locate the Clip (11) attached to the

underside of the Frame. Insert the Reed Switch (6) into

the Clip as shown. Next, locate the Magnet (12) on the

left Flywheel (9). Turn the Flywheel until the Magnet is

aligned with the Reed Switch. Move the Reed Switch

so that there is a 1/8” gap between the Reed Switch

and the Magnet. Then, tighten the M4 x 12mm Screw

(3) in the Clip.

29 12

311

1/8”

View from

below

35 4b

Tab

6. The Console (1) requires two “AAA” batteries. Alkaline

batteries are recommended. Press the indicated tab on

the Battery Cover (27) and remove the Battery Cover.

Insert two batteries into the two battery clips; make sure

that the negative (–) ends of the batteries are touch-

ing the springs in the battery clips.

9. Make sure that all parts are properly tightened before you use the treadmill. To protect the floor or carpet,

place a mat under the treadmill.

34 33

5. Hold the Handrail (5) near the Left and Right Uprights (35,

36). Connect the Handrail Wire (2) to the Reed Switch

Wire (6). Insert the Wires down into the Left Upright.

Attach the Handrail (5) to the Uprights (35, 36) with four

M8 x 15mm Bolts (33) and four M8 Washers (34). Be

careful not to pinch the Wires (2, 6).

Batteries

7. See drawing 7a. Hold the Console (1) near the Handrail

(5). Connect the wire on the Console to the Handrail

Wire (2). Attach the Console to the Handrail with two M4

x 12mm Screws (3). Make sure that the wires are not

pinched.

See drawing 7b. Press the Battery Cover (27) back onto

the Console (1).

8. Remove the paper backing from the Adhesive Clip (30).

Press the Adhesive Clip onto the left side of the Frame

(29) in the indicated location. Press the Allen Wrench

(20) into the Adhesive Clip.

Make sure that the walking belt is properly tightened (see

SYMPTOM 3 on page 8).

7a 7b 1

LUBRICATING THE WALKING PLATFORM

Before the treadmill is used, the walking platform

should be lubricated. Open the included lubricant

packet. Reach under one side of the walking belt as

far as you can, and apply half of the lubricant to the

walking platform. Then, reach under the other side of

the walking belt and apply the remaining lubricant.

After you have applied the lubricant, walk on the

treadmill for a few minutes to spread the lubricant.

STEP-BY-STEP CONSOLE OPERATION

Before the console can be operated, batteries must be

installed (see assembly step 6 on page 5). If there is a

thin sheet of plastic on the console, remove the plastic.

The console features six modes:

• Speed—This mode displays your speed, in miles

per hour.

• Distance—This mode displays the number of miles

you have walked.

• Time—This mode displays the elapsed time.

• Odometer—This mode displays the distance that

the walking belt has moved since the batteries were

changed.

• Calorie—This mode displays the approximate num-

ber of calories you have burned.

• Scan—This mode displays the Speed, Distance,

Time, Odometer, and Calorie modes.

Follow the steps below to operate the console.

1. Turn on the power.

To turn on the power, press the console button or

begin walking. Note: If batteries were just installed,

the power will already be on.

2. Track your progress with the six modes.

When the power is

turned on, the Scan

mode will be selected

and the SCAN indica-

tor will appear. The

console will display

the Speed, Distance,

Time, Odometer, and

Calorie modes, for about six seconds each, in a

repeating cycle.

To select only the Speed, Distance, Time,

Odometer, or Calorie mode, press the console but-

ton until only the SPEED, DIST, TIME, ODO, or

CAL indicator appears in the display. Make sure

that the SCAN indicator does not appear.

To reset all modes (except for the odometer mode),

press the console button for about three seconds.

3. Turn off the power.

To turn off the power, simple wait for a few minutes.

If the walking belt is not moved and the console

button is not pressed for a few minutes, the power

will turn off automatically.

TREADMILL OPERATION

SCAN Indicator

Apply lubricant here

INCLINE ADJUSTMENT

The incline of the treadmill can be adjusted to any of

three positions. Hold the front of the Frame (29), and

remove the two Pins (4). Raise or lower the Frame,

align the holes in the Frame with one of the sets of

holes in the Uprights (35, 36), and then re-insert the

Pins. Make sure both Pins are fully inserted at the

same height.

FOLDING THE TREADMILL FOR STORAGE

When the treadmill is not in use, it can be folded to

the compact storage position. CAUTION: You must

be able to safely lift 25 pounds (11 kg) to raise,

lower, or move the treadmill.

1. Hold the treadmill with your hands in the locations

shown below. CAUTION: To decrease the possi-

bility of injury, bend your legs and keep your

back straight. As you raise the treadmill, make

sure to lift with your legs rather than your back.

Raise the treadmill to the vertical position.

2. Hold the treadmill

securely with your

left hand as

shown. Insert a

Pin (4) into the

hole in the right

side of the Right

Upright (36) and

into the Frame

(29) as far as it

will go. Attach the

Spring Clip (42)

over the notch

near the end of the Pin. Note: Squeezing the han-

dles on the Spring Clip will help you to slide it onto

the Pin.

LOWERING THE TREADMILL FOR USE

1. Hold the treadmill securely with your left hand as

shown in drawing 2 above. Squeeze the handles

on the Spring Clip (42) and pull out the Pin (4).

Pivot the treadmill down a few inches and re-insert

the Pin and attach the Spring Clip.

2. Hold the treadmill firmly with both hands, and lower

the treadmill to the floor. CAUTION: To decrease

the possibility of injury, bend your legs and

keep your back straight.

CAUTION: Make sure both Pins

(4) are fully inserted at the same height.

35 36

MAINTENANCE AND TROUBLESHOOTING

Most treadmill problems can be solved by following the simple steps below. Find the symptom that

applies, and follow the steps listed. If further assistance is needed, call toll-free 1-800-4-MY-HOME®

(1-800-469-4663).

1. SYMPTOM: THE CONSOLE DOES NOT

FUNCTION PROPERLY

a. Replace the batteries in the console (see assem-

bly step 6 on page 5).

b. Make sure that the reed switch is properly adjust-

ed (see assembly step 4 on page 4).

c. Make sure that the handrail wire is plugged fully

into the wire on the console (see assembly step 7

on page 5).

d. The console, like most electronics, is susceptible

to static electricity build-up caused by certain

types of clothing or by the operation of the tread-

mill. If the display is blank or gives incorrect read-

ings, apply an anti-static spray to the handrail.

Anti-static spray is available where laundry sup-

plies are sold.

2. SYMPTOM: THE WALKING BELT DOES NOT

MOVE SMOOTHLY

a. If the walk-

ing belt is

overtight-

ened, per-

formance

may be

reduced and

the walking

belt may be

permanently

damaged.

Using the

allen

wrench, turn both rear roller adjustment bolts

counterclockwise 1/4 of a turn. When the tension

of the walking belt is correct, you should be able

to lift each side of the walking belt 2 to 3 inches.

Walk on the treadmill for a few minutes. Repeat

until the walking belt is properly tightened. Be

careful to keep the walking belt centered.

3. SYMPTOM: THE WALKING BELT SLIPS OR IS

OFF-CENTER

a. If the walking

belt slips

when walked

on, use the

allen wrench to

turn both

adjustment

bolts clockwise,

1/4 of a turn. When the walking belt is correctly

tightened, you should be able to lift each side of

the walking belt 2 to 3 inches. Walk on the tread-

mill for a few minutes. Repeat until the walking

belt is properly tightened. Be careful to keep the

walking belt centered.

b. If the walking

belt has shift-

ed to the left

side, use the

allen wrench to

turn the left

adjustment bolt

clockwise, and

the right adjustment bolt counterclockwise, 1/4 of

a turn each. Be careful not to overtighten the

walking belt. Walk on the treadmill for a few min-

utes. Repeat until the walking belt is centered.

c. If the walking

belt has shift-

ed to the right

side, use the

allen wrench to

turn the left

adjustment bolt

counterclock-

wise, and the right adjustment bolt clockwise, 1/4

of a turn each. Be careful not to overtighten the

walking belt. Walk on the treadmill for a few min-

utes. Repeat until the walking belt is centered.

2"–3"

Bolts

Walking Belt

The following guidelines will help you to plan your

exercise program. Remember that proper nutrition and

adequate rest are essential for successful results.

WHY EXERCISE?

Exercise has proven essential for good health and

well-being. A well-rounded exercise program helps to

develop a stronger and more efficient heart, improved

respiratory function, increased stamina, better weight

management, increased ability to handle stress, and

greater self-esteem.

EXERCISE INTENSITY

Whether your goal is to burn fat or to strengthen your

cardiovascular system, the key to achieving the

desired results is to exercise with the proper intensity.

The proper intensity level can be found by using your

heart rate as a guide. The chart below shows

recommended heart rates for fat burning and aerobic

exercise.

To find the proper heart rate for you, first find your age

near the bottom of the chart (ages are rounded off to

the nearest ten years). Next, find the three numbers

above your age. The three numbers are your “training

zone.” The lower two numbers are recommended

heart rates for fat burning; the highest number is the

recommended heart rate for aerobic exercise.

Burning Fat

To burn fat effectively, you must exercise at the proper

intensity level for a sustained period of time. During

the first few minutes of exercise, your body uses easi-

ly accessible carbohydrate calories for energy. Only

after the first few minutes does your body begin to use

stored fat calories for energy. If your goal is to burn

fat, adjust the intensity of your exercise until your

heart rate is between the lower two numbers in your

training zone as you exercise.

Aerobic Exercise

If your goal is to strengthen your cardiovascular sys-

tem, your exercise must be “aerobic.” Aerobic exercise

is activity that requires large amounts of oxygen for

prolonged periods of time. This increases the demand

on the heart to pump blood to the muscles, and on the

lungs to oxygenate the blood. For effective aerobic

exercise, adjust the intensity of your exercise until

your heart rate is near the highest number in your train-

ing zone.

HOW TO MEASURE YOUR HEART RATE

To measure your

heart rate, stop exer-

cising and place two

fingers on your wrist

as shown. Take a

six-second heartbeat

count, and multiply

the result by ten to

find your heart rate.

(A six-second count is used because your heart rate

drops quickly when you stop exercising.) If your heart

rate is too high, decrease the intensity of your exer-

cise. If your heart rate is too low, increase the intensity

of your exercise.

WORKOUT GUIDELINES

Each workout should include the following three impor-

tant parts:

A warm-up, consisting of five to ten minutes of

stretching and light exercise. This will increase your

body temperature, heart rate, and circulation in prepa-

ration for exercise.

Training zone exercise, including 20 to 30 minutes of

exercise with your heart rate in your training zone.

CONDITIONING GUIDELINES

WARNING: Before beginning this

or any exercise program, consult your physi-

cian. This is especially important for individu-

als over the age of 35 or individuals with pre-

existing health problems.

1 1 Console

2 1 Handrail Wire

3 3 M4 x 12mm Screw

4 3 Pin

5 1 Handrail

6 1 Reed Switch/Wire

7 10 M5 x 20mm Bolt

8 2 Frame Endcap

9 1 Front Roller/Flywheel

10 4 M5 x 10mm Bolt

11 1 Reed Switch Clip

12 1 Magnet

13 4 M8 Nylon Nut

14 1 Base

15 2 Base Pad

16 2 Roller Guard

17 2 Base Endcap

18 1 Walking Belt

19 1 Walking Platform

20 1 Allen Wrench

21 2 Frame Foot

22 2 Rear Roller Adjustment Bolt

23 2 Rear Roller Washer

24 2 Frame Plate

25 1 Rear Roller

26 1 Wrench

27 1 Battery Cover

28 1 Hood

29 1 Frame

30 1 Adhesive Clip

31 2 Handrail Endcap

32 2 Handrail Foam Grip

33 4 M8 x 15mm Bolt

34 4 M8 Washer

35 1 Left Upright

36 1 Right Upright

37 4 M8 Curved Washer

38 4 M8 x 50mm Bolt

39 1 Grommet

40 1 Warning Decal

41 2 Platform Cover

42 1 Spring Clip

# 1 User’s Manual

# These parts are not illustrated.

Key No. Qty. Description Key No. Qty. Description

Specifications are subject to change without notice. If a part is missing, call toll-free 1-800-999-3756. See the

back cover for information about ordering replacement parts.

PART LIST—Model No. 831.291030 R0903A

A cool-down, consisting of five to ten minutes of

stretching. Stretching after exercise is effective for

increasing flexibility and helps to offset problems

caused when you stop exercising suddenly.

EXERCISE FREQUENCY

To maintain or improve your condition, plan three

workouts each week, with at least one day of rest after

each workout. After a few months of regular exercise,

you may complete up to five workouts each week, if

desired.

Instead of waiting for a convenient time to exercise,

plan a specific time. The morning hours work well for

many, and the self-discipline required to rise early and

exercise increases productivity throughout the day. For

others, exercising before dinner helps them to relax.

Whatever time you choose, be consistent. The key to

success is to make exercise a regular and enjoyable

part of your everyday life.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Weslo Tretmühle Handbücher

Weslo

Weslo Cadence 3260 Bedienungsanleitung

Weslo

Weslo Cadence 955 Bedienungsanleitung

Weslo

Weslo Cadence G25 Treadmill Bedienungsanleitung

Weslo

Weslo CADENCE 1005 Bedienungsanleitung

Weslo

Weslo Cadence Dl40 WLTL51691 Bedienungsanleitung

Weslo

Weslo CADENCE LX 15 Bedienungsanleitung

Weslo

Weslo Cadence 60 CT Bedienungsanleitung

Weslo

Weslo Cadence 21.5 Treadmill Benutzerhandbuch

Weslo

Weslo Cadence 255 Dr Treadmill Bedienungsanleitung

Weslo

Weslo Cadence 70 Treadmill Bedienungsanleitung

Weslo

Weslo WETL91070 Bedienungsanleitung

Weslo

Weslo Cadence LS 8 Bedienungsanleitung

Weslo

Weslo Crosswalk 5.0t Treadmill Benutzerhandbuch

Weslo

Weslo Cadence Dx5 Bedienungsanleitung

Weslo

Weslo WLTL21280 Bedienungsanleitung

Weslo

Weslo CADENCE 850 WETL85061 Bedienungsanleitung

Weslo

Weslo Cadence 400 Treadmill Bedienungsanleitung

Weslo

Weslo WLTL211041 Bedienungsanleitung

Weslo

Weslo WCTL84090 Bedienungsanleitung

Weslo

Weslo Cadence 55 Bedienungsanleitung

Weslo

Weslo CADENCE 340 CS Bedienungsanleitung

Weslo

Weslo Cadence 5.0 Treadmill Bedienungsanleitung

Weslo

Weslo Cadence 905 Bedienungsanleitung

Weslo

Weslo Crosswalk 5.0t Treadmill Bedienungsanleitung

Beliebte Tretmühle Handbücher anderer Marken

Treadly

Treadly TREADLY 2 Bedienungsanleitung

HEALTH ONE

HEALTH ONE Walk Ro Bedienungsanleitung

NordicTrack

NordicTrack T7.5 S Bedienungsanleitung

Gold's Gym

Gold's Gym ADVANTAGE GGTL12920 Bedienungsanleitung

Merax

Merax MS282992 Bedienungsanleitung

FYTTER

FYTTER RU-2SX Bedienungsanleitung

Precor

Precor 903 Bedienungsanleitung

FitLogic

FitLogic freewill d225 Bedienungsanleitung

HOP-SPORT

HOP-SPORT ESTIMA HS-3200LB Bedienungsanleitung

Horizon Fitness

Horizon Fitness Adventure 5 Plus Bedienungsanleitung

Stamia

Stamia InMotion II Bedienungsanleitung

Smooth Fitness

Smooth Fitness EVO 3i Bedienungsanleitung

NordicTrack

NordicTrack NETL81810.0 Bedienungsanleitung

Schwinn

Schwinn 830/Journey 8.0 Bedienungsanleitung

Keys Fitness

Keys Fitness HealthTrainer HT-740T Bedienungsanleitung

Spirit

Spirit XT8 Bedienungsanleitung

NordicTrack

NordicTrack T 14.0 Treadmill Bedienungsanleitung

Master

Master F22 Bedienungsanleitung