Federal Signal Corporation ESB-IMP08R Bedienungsanleitung

Safety Message to Installers of Siren Speakers

People’s lives depend on your proper installation and servicing of Federal Signal products. It is

important to read and follow all instructions shipped with this product and the original product. Listed below are some

other important safety instructions and precautions you should follow:

Before Installation

Qualications

• Toproperlyinstallanelectronicsiren,youmusthaveagoodunderstandingofautomotiveelectrical

proceduresandsystems,alongwithprociencyintheinstallationandserviceofsafetywarning

equipment. Always refer to the vehicle’s service manuals when installing equipment on a vehicle.

Sound Hazards

• Yourhearingandthehearingofothers,inornearyouremergencyvehicle,couldbedamagedby

loudsounds.Thiscanoccurfromshortexposurestoveryloudsounds,orfromlongerexposures

tomoderatelyloudsounds.Forhearingconservationguidance,refertofederal,state,orlocal

recommendations.OSHAStandard1910.95offersguidanceon“PermissibleNoiseExposure.”

• Alleffectivesirensandhornsproduceloudsounds(120dB)thatmaycausepermanenthearingloss.

Alwaysminimizeyourexposuretosirensoundandwearhearingprotection.Donotsoundthesiren

indoorsorinenclosedareaswhereyouandotherswillbeexposedtothesound.

• FederalSignalsirenampliersandspeakersaredesignedtoworktogetherasasystem.Combining

asirenandspeakerfromdifferentmanufacturersmayreducethewarningeffectivenessofthesiren

systemandmaydamagethecomponents.Youshouldverifyortestyourcombinationtomakesurethe

systemworkstogetherproperlyandmeetsfederal,stateandlocalstandardsorguidelines.

During Installation

• DONOTgetmetalshavingsinsidetheproduct.Metalshavingscancausethesystemtofail.If

drillingmustbedoneneartheunit,placeanESD-approvedcoverovertheunittopreventmetal

shavings from entering the unit. Inspect the unit after mounting to be sure there are no shavings

present in or near the unit.

• DONOTconnectthissystemtothevehiclebatteryuntilALLotherelectricalconnectionsare

made,mountingofallcomponentsiscomplete,andyouhaveveriedthatnoshortsexist.Ifwiring

isshortedtothevehicleframe,highcurrentconductorscancausehazardoussparksresultingin

electricalresoryingmoltenmetal.

• Besurethesirenamplierandspeaker(s)inyourinstallationhavecompatiblewattageratings.

• Inorderfortheelectronicsirentofunctionproperly,thegroundconnectionmustbemadetothe

NEGATIVEbatteryterminal.

• Soundoutputwillbeseverelyreducedifanyobjectsareinfrontofthespeaker.Ifmaximumsound

outputisrequiredforyourapplication,youshouldensurethatthefrontofthespeakerisclearofany

obstructions.

ESB-IMP08R Mounting Bracket Kit for the ES100

Speaker in the 2006 and Newer Chevy®Impala®

2562598A REV. A 411

ES100 Speaker Mounting Instructions

2Model IMP08R Mounting Bracket Kit

• Installthespeaker(s)asfarforwardonthevehicleaspossible,inalocationthatprovidesmaximum

signaling effectiveness while minimizing the sound reaching the vehicle’s occupants. Refer to the

NationalInstituteofJusticeguide500-00forfurtherinformation.

• Mountingthespeakersbehindthegrillewillreducethesoundoutputandwarningeffectivenessofthe

sirensystem.Beforemountingspeakersbehindthegrille,makesurethevehicleoperatorsaretrained

and understand that this type of installation is less effective for warning others.

• Soundpropagationandwarningeffectivenesswillbeseverelyreducedifthespeakerisnotfacing

forward.Carefullyfollowtheinstallationinstructionsandalwaysinstallthespeakerwiththeprojector

facing forward.

• DONOTinstallthespeaker(s)orroutethespeakerwireswheretheymayinterferewiththeoperation

of airbag sensors.

• Installationoftwospeakersrequiresthatyouwirethespeakersinphase.

• Neverattempttoinstallaftermarketequipment,whichconnectstothevehiclewiring,without

reviewingavehiclewiringdiagram,whichisavailablefromthevehiclemanufacturer.Insurethat

yourinstallationwillnotaffectvehicleoperationandsafetyfunctionsorcircuits.Alwayscheck

vehicle for proper operation after installation.

• DONOTinstallequipmentorroutewiringorcordinthedeploymentpathofanairbag.

• Locatethecontrolheadsothevehicle,controls,andmicrophonecanbeoperatedsafely.

• Whendrillingintoavehiclestructure,besurethatbothsidesofthesurfaceareclearofanythingthat

could be damaged.

• Ifavehicleseatistemporarilyremoved,verifywiththevehiclemanufactureriftheseatneedstobe

recalibrated for proper airbag deployment.

After Installation

• Afterinstallation,testthesirensystemandlightsystemtoensurethatitisoperatingproperly.

• Testallvehiclefunctions,includinghornoperation,vehiclesafetyfunctionsandvehiclelightsystems,

to ensure proper operation. Ensure that installation has not affected vehicle operation or changed any

vehicle safety function or circuit.

• Aftertestingiscomplete,provideacopyoftheseinstructionstotheinstructionalstaffandall

operating personnel.

• Filetheseinstructionsinasafeplaceandrefertothemwhenmaintainingorreinstallingtheproduct.

Failuretofollowallsafetyprecautionsandinstructionsmayresultinpropertydamage,seriousinjury,ordeath.

An Overview of the Kit

MountingkitESB-IMP08RmountsanES100speakerina2006andnewerChevrolet®Impala®.Thekit

mountsthespeakerbelowthedriver-sideheadlightonavehicleframememberusingexistingholes.Thiskit

workswhenaRumblersystemisinstalledinthevehicle.

ES100 Speaker Mounting Instructions

Model IMP08R Mounting Bracket Kit

Before You Begin

IMPORTANT:TheES100speakercomplieswiththerequirementsofSAEJ1849EVS3andCCRTitle13

ClassAwhenitisusedwithFederalSignalelectronicsirens.

TheES100speakerisacompactspeakerintendedtobemountedwiththesuppliedmountingsysteminthe

2006andnewerChevroletImpala.IftheES100speakerisinstalledwithanothermountingsystem,thesafety

and effectiveness of the installation must be carefully evaluated.

Unpacking the Kit

Afterunpackingtheproduct,inspectitfordamagethatmayhaveoccurredintransit.Ifithasbeendamaged,

donotattempttoinstalloroperateit.Fileaclaimimmediatelywiththecarrier,statingtheextentofdamage.

Carefullycheckallenvelopes,shippinglabels,andtagsbeforeremovingordestroyingthem.Ensurethatthe

partslistedinTable1areincludedinthepackage.Ifyouaremissinganyparts,contactCustomerSupportat

1-800-264-3578,7a.m.to5p.m.,MondaythroughFriday(CT).

Table 1 Kit contents

Qty. Description Part Number Qty. Description Part Number

1 Bracket Assy. 8567212 3 Lockwasher, Split, 1/4"7074A016

3 Screw, 1/4" x 5/8", Type B 7011165-10 3 Washer, Flat, 1/4"7072A024

Installing the Speaker

ES100 MOUNTING PRECAUTIONS—To avoid reducing the sound output and

damaging the speaker, ensure that the speaker is mounted with the wires

protruding from the bottom of the speaker.

Tomountandwirethespeaker:

1. SeeFigure1.Attachthespeakertothebracketassemblyusingtheangeboltssuppliedwiththespeaker.

Figure 1 Speaker attached to bracket

290A6522B

BRACKET ASSEMBLY

(8567212)

FLANGE BOLT (2)

SUPPLIED WITH

SPEAKER

ES100 SPEAKER

ES100 SPEAKER WIRES

MUST PROTRUDE

FROM BOTTOM

ES100 Speaker Mounting Instructions

4Model IMP08R Mounting Bracket Kit

2. SeeFigure2.Raisethevehiclehood.Removethedriver-sideheadlight.

Figure 2 Remove driver-side headlight

290A6523

REMOVE AND RETAIN SCREWS

(NOTE: SECOND SCREW IS HIDDEN IN THIS VIEW)

3. SeeFigure3.Securethebracketassemblywiththespeakertothevehiclewiththesupplied1/4"TypeB

screws,lockwashers,andatwashers.

Figure 3 Bracket assembly with speaker attached to vehicle frame

290A6524B

VEHICLE FRAME

1/4" FLAT WASHER (3)

(7072A024)

1/4" SPLIT LOCKWASHER (3)

(7074A016)

1/4" TYPE B SCREW (3)

(7011165-10)

ES100 Speaker Mounting Instructions

Model IMP08R Mounting Bracket Kit

4. Connectthetwoleadsfromthespeakertotheelectronicsiren’sspeakercable.

5. Toconnecttwospeakers,itisnecessarytoconnecttheminphase.Connectthetworedspeakerleads

tooneleadofthecablefromtheelectronicsiren.Connectthetwoblackspeakerleadstotheotherlead

of the cable from the electronic siren. Refer to the instructions provided with the electronic siren for

additional details.

6. Testthespeakersforproperoperationaswellastheemergencywarningsystemtoensurethatitis

operatingproperly.Seethenexttwosectionsforwarningsandinstructions.

7. Replacethedriver-sideheadlight.

Safety Message to Operators of Federal Signal Electronic Sirens and Light/

Sound Systems

ThelivesofpeopledependonyoursafeoperationofFederalproducts.Itisimportanttoreadandfollowall

instructionsshippedwiththeproducts.Inaddition,listedbelowaresomeotherimportantsafetyinstructions

and precautions you should follow:

Qualications

• Toproperlyuseanelectronicsirenandspeaker(s),youmusthaveagoodunderstandingofgeneral

vehicleoperation,ahighprociencyintheuseofsafetywarningequipment,andthoroughknowledge

ofstateandfederalUNIFORMTRAFFICCODES.

Sound Hazards

• Yourhearingandthehearingofothers,inorclosetoyouremergencyvehicle,couldbedamaged

byloudsounds.Thiscanoccurfromshortexposurestoveryloudsounds,orfromlongerexposures

tomoderatelyloudsounds.Forhearingconservationguidance,refertofederal,state,orlocal

recommendations.OSHAStandard1910.95offersguidanceon“PermissibleNoiseExposure.”

• Alleffectivesirensandhornsproduceloudsounds(120dB)thatmaycausepermanenthearingloss.

Alwaysminimizeyourexposuretosirensound,rollupyourwindowsandwearhearingprotection.

Donotsoundthesirenindoorsorinenclosedareaswhereyouandotherswillbeexposedtothe

sound. Only use the siren for emergency response situations.

Sound Limitations

• Beforeusingthevehicle,checktoseeifthesirenspeakersareconcealedfromview.Ifthesiren

speakerisnotinclearviewonthefrontofthevehicle,useextracautionwhenoperatingthevehicle.A

concealedsirenspeakerinstallationislesseffectiveatwarningothers.

• Maximumsoundoutputwillbeseverelyreducedifanyobjectsareinfrontofthespeaker.Ifyour

installationhasobstructionsinfrontofthespeaker,driveevenmorecautiously.

• Frequentlyinspectthespeakertoensurethatitisclearofanyobstruction,suchasmudorsnow,

whichwillreducemaximumsoundoutput.

ES100 Speaker Mounting Instructions

6Model IMP08R Mounting Bracket Kit

Signaling Limitations

• Beawarethattheuseofyourvisualandaudiblesignalingdevicesdoesnotgiveyoutherighttoforce

yourwaythroughtrafc.Youremergencylights,siren,andactionsareREQUESTINGtheright-of-

way.

• Althoughyourwarningsystemisoperatingproperly,itmaynotalerteveryone.Peoplemaynothear,

see,orheedyourwarningsignal.Youmustrecognizethisfactandcontinuedrivingcautiously.

• Situationsmayoccurwhichobstructyourwarningsignalwhennaturalorman-madeobjectsare

betweenyourvehicleandothers.Thiscanalsooccurwhenyouraiseyourhoodortrunklid.Ifthese

situationsoccur,beespeciallycareful.

Driving Limitations

• Atthestartofyourshift,youshouldensurethatthelight/soundsystemissecurelyattachedtothe

vehicle and operating properly.

• Iftheuniquecombinationofemergencyvehicleequipmentinstalledinyourvehiclehasresultedin

thesirencontrolsbeinginstalledinapositionthatdoesnotallowyoutooperatethembytouchonly,

OPERATETHECONTROLSONLYWHILEYOURVEHICLEISSTOPPED.

• Ifdrivingconditionsrequireyourfullattention,youshouldavoidoperatingthesirencontrolswhile

the vehicle is in motion.

Continuing Education

• Filetheseinstructionsinasafeplaceandrefertothemperiodically.Giveacopyoftheseinstructions

to new recruits and trainees.

Failuretofollowthesesafetyprecautionsmayresultinpropertydamage,seriousinjury,ordeath.

Testing the Installation

SOUND HAZARD—All effective sirens and horns produce loud sounds (120 dB)

that may cause permanent hearing loss. Always minimize your exposure to the

sound of the siren or horn and wear hearing protection. Do not sound the siren

or horn indoors or in enclosed areas where you and others will be exposed to the

sound.

LIGHT HAZARD—To be an effective warning device, an emergency warning system

produces bright light that can be hazardous to your eyesight when viewed at a

close range. Do not stare directly into the lights at a close range or permanent

damage to your eyesight may occur.

Aftertestingthesireninstallation,testtheemergencywarningsystemtoensurethatitisoperatingproperly.

Alsotestallvehiclefunctions,includinghornoperation,vehiclesafetyfunctions,andvehiclelighting

systems to ensure proper operation. Ensure that the installation has not affected the vehicle operation

orchangedanyvehiclesafetyfunctionsorcircuits.Aftertestingiscomplete,provideacopyofthese

instructions to the instructional staff and all operating personnel.

ES100 Speaker Mounting Instructions

Model IMP08R Mounting Bracket Kit

Donottestthesoundandlightsystemofthevehiclewhiledriving.Operatingthevehiclewarningsystems

mayposeahazardtotheoperatorandotherdriversifthesystemsdonotfunctionasexpected.Testthe

vehicle only in a controlled environment.

Getting Technical Support and Service

Thisspeakerhasnoeld-serviceableparts.Openingthespeakerwillvoidthewarranty.TheFederalSignal

factorycanandwillserviceyourspeaker.Ifyouareexperiencingproblemswiththespeaker,pleasecontact:

FederalSignalCorporation

ServiceDepartment

Public Safety Systems

Phone:1-800-433-9132

Fax:1-800-343-9706

Email: [email protected]

Ordering Replacement Parts

Toorderreplacementpartsforthemountingsystem,pleasecontactyourlocaldealer/distributoror:

CustomerSupport

FederalSignalCorporation

Phone:1-800-264-3578

Returning a Product to Federal Signal

BeforereturningaproducttoFederalSignal,call800-264-3578,800-433-9132,or800-824-0254toobtain

aReturnedMerchandiseAuthorizationnumber(RMAnumber).Toexpeditetheprocesspleasebeprepared

with the following information:

• YourFederalSignalcustomeroraccountnumber.

• Thepurchaseordernumberunderwhichtheitemswerepurchased.

• Theshippingmethod.

• Themodelorpartnumberoftheproductbeingreturned.

• Thequantityofproductsbeingreturned.

• Dropshipinformationasneeded.

• Anyestimaterequired.

WhenyoureceiveyourRMANumber:

• WritetheRMAnumberontheoutsideoftheboxofreturneditems.

• ReferencetheRMAnumberonyourpaperworkinsideofthebox.

• WritetheRMAnumberdown,sothatyoucaneasilycheckonstatusofthereturnedequipment.

ES100 Speaker Mounting Instructions

8Model IMP08R Mounting Bracket Kit

SendallmaterialwiththeissuedRMANumberto:

FederalSignalCorporation

Public Safety Systems

2645FederalSignalDrive

UniversityPark,IL60484-3167

Attn:ServiceDepartment

RMA:#__________

800-433-9132

800-343-9706(fax)

www.fedsig.com

2645 Federal Signal Drive, University Park, IL 60484-3167

Tel.: (800) 264-3578 • Fax: (800) 682-8022

www.fedsig.com

Chevrolet,Chevy,andImpalaareregistered

trademarksofGeneralMotorsCorporation.

Inhaltsverzeichnis

Andere Federal Signal Corporation Autozubehör Handbücher

Federal Signal Corporation

Federal Signal Corporation DFC-WC-DUR21 Bedienungsanleitung

Federal Signal Corporation

Federal Signal Corporation ESB-CRG07 Bedienungsanleitung

Federal Signal Corporation

Federal Signal Corporation SIFMH Handbuch

Federal Signal Corporation

Federal Signal Corporation Vision SLR Original Betriebsanleitung

Federal Signal Corporation

Federal Signal Corporation GH1K Bedienungsanleitung

Federal Signal Corporation

Federal Signal Corporation XHK-SD Bedienungsanleitung

Federal Signal Corporation

Federal Signal Corporation Legend LGD Einrichtungshandbuch

Federal Signal Corporation

Federal Signal Corporation CommCenter D1 Series Kurzanleitung

Federal Signal Corporation

Federal Signal Corporation Cuda TriOptic 351014F Series Bedienungsanleitung

Federal Signal Corporation

Federal Signal Corporation 7000 Bedienungsanleitung

Federal Signal Corporation

Federal Signal Corporation DFC Series Bedienungsanleitung

Federal Signal Corporation

Federal Signal Corporation SpectraLux SIFZ Front ILS Handbuch

Federal Signal Corporation

Federal Signal Corporation Commander 371LED-120A Handbuch

Federal Signal Corporation

Federal Signal Corporation VIPER EXT Bedienungsanleitung

Federal Signal Corporation

Federal Signal Corporation Vision SLR Betriebsanleitung

Federal Signal Corporation

Federal Signal Corporation ML-PT Bedienungsanleitung

Federal Signal Corporation

Federal Signal Corporation VSLR1-IPX Series Bedienungsanleitung

Federal Signal Corporation

Federal Signal Corporation Commander 371LED-120B Handbuch

Federal Signal Corporation

Federal Signal Corporation HighLighter Montageanleitung

Federal Signal Corporation

Federal Signal Corporation SpectraLux SIFZJ FSJoin Handbuch

Federal Signal Corporation

Federal Signal Corporation Legend Bedienungsanleitung

Federal Signal Corporation

Federal Signal Corporation Viewpoint FV Series Bedienungsanleitung

Federal Signal Corporation

Federal Signal Corporation RAYDIAN Bedienungsanleitung

Federal Signal Corporation

Federal Signal Corporation 501900-31XX Bedienungsanleitung

Beliebte Autozubehör Handbücher anderer Marken

James Baroud

James Baroud Odyssey Bedienungsanleitung

Motorola

Motorola i50sx Bedienungsanleitung

Yakima

Yakima 9MM STANDARD BIKE MOUNT Bedienungsanleitung

Feniex

Feniex T3 Bedienungsanleitung

Kia

Kia E8300-4D000 Bedienungsanleitung

Brink

Brink 756843 Bedienungsanleitung

Whispbar

Whispbar K085W Bedienungsanleitung

v.link

v.link CI-VL2-PC-HSD Bedienungsanleitung

Viking

Viking Stack-Rack Kurzanleitung zur Einrichtung

Aries

Aries 203015 Bedienungsanleitung

Choetech

Choetech AT0005 Bedienungsanleitung

ZZ2

ZZ2 ZZAIR-PRO Bedienungsanleitung

Holman

Holman 4A80L Bedienungsanleitung

Thule

Thule 2075 Bedienungsanleitung

Motorola

Motorola T325 Bedienungsanleitung

TAUBENREUTHER

TAUBENREUTHER 16-3950 Installationsanleitung

DV8

DV8 FBJL-02 Bedienungsanleitung

Prorack

Prorack K1163 Bedienungsanleitung