Ski-Doo 1982 Blizzard 5500 MX Bedienungsanleitung

1982

OPERATOR1S

MANUAL

"Lr

suernarks ot Bombardier Inc.

Litho'd

in Canada All

tiqhts

reserved .tJ

Bombardier

Inc 414454100

model

V.I.N.

purchase date _

warranty expiry date

To be completed by dealer at time of sale.

DEALER IMPRINT AREA

MOTO-SKI

FUTURA

SPIRIT

NUVIK

MIRAGE

SUPER SONIC

ULTRA SONIC

SONIC

EVEREST

CITATION

OLYMPIQUE

T'NT

NORDIK

SKANDIC

The following are trademarks of Bom-

bardier Inc.

BOMBARDIER

SKI-DOO

ALPINE

BLIZZARD

CARRY-BOOSE

ELAN

ELITE

GRAND PRIX SPECIAL

TECHNICAL PUBLICA

nONS

AFTER SALES SERVICE DEPARTMENT

BOMBARDIER INC.

VALCOURT, QUEBEC

CANADA,

JOE2LO

FOREWORD

The Operator Manual and the Snow-

mobile Safety handbook have been

prepared to acquaint the owner Ioper-

ator of a new snowmobile with the var-

ious vehicle controls maintenance and

safe operating instructions. Each is in-

dispensable for the proper use of the

product, and should be kept

with

the

vehicle at all times.

Should you have any questions per-

taining to the warranty and its applica-

tion, please consult the

"Often

Asked

Question" section of this manual, or

your selling dealer.

This manual uses the following sym-

bols.

WARNING:

Identifies an instruc-

"..

tion which, if not followed, could

cause personal injury.

...

CAUTION: Denotes an instruc-

,..

tion which, if not followed, could

severely damage vehicle components.

ONOTE: Indicates supplementary

information needed to fully com-

plete an instruction.

Although the mere reading of such in-

formation does not eliminate the haz-

ard, your understanding of the infor-

mation will promote its correct use.

SAFETY

MAINTENANCE

Observe the following

precautions:

• Throttle mechanismshould becheck-

ed for free movement before starting

engine.

• The snowmobile engine can be

stopped by activating the emergen-

cy cut-out or tether switches or turn-

ing

off

the key.

• Clean and check operation of the

headlight

tail light and brake light.

• Engineshould be running only when

pulley guard is secured in place.

• Never run the engine

without

drive

belt installed. Running an unloaded

engine can prove to be dangerous.

• Never run the engine when the track

is raised

off

the ground.

• It can be dangerous to run engine

with the hood removed.

• Gasoline is flammable and explosive

under certain conditions. Always

manipulate in a well ventilated area.

Do not smoke or allow open flames

or sparks in the vicinity. If gasoline

fumes are noticed while driving, the

cause should be determined and

corrected

without

delay.

• Maintain your vehicle in top mechan-

ical condition "atall times.

• Your snowmobile is not designed to

be driven or operated on black top,

bare earth, or other abrasive sur-

faces. On such surfaces abnormal

and excessive wear of critical parts

is inevitable.

• Your snowmobile is not designed to

be operated on public streets, road

or highways. In most States and

Provinces, it is considered an illegal

operation.

•Installation of other than standard

equipment, including ski-spreaders,

bumpers, pack racks, etc., could

severely affect the stability and safe-

ty of your vehicle. Avoid adding on

accessories that alter the basic ve-

hicle configuration.

• Whenever the vehicle is parked out-

doors, overnight or for a long peri-

od, it issuggestedto protect it against

the inclemency of the weather with

asnowmobile cover.

• Do not lubricate throttle

and/or

brake cables and housings.

• Only perform procedures as detailed

in this manual. Unless otherwise

specified, engine should be turned

OFF for all lubrication and mainte-

nance procedures.

• This vehicle is designed for the

driver only. No provisions have been

made for a passenger.

•

PLEASE

READAND UNDERSTAND

ALL WARNINGS AND CAUTIONS

IN THIS

MANUAL

AND ON THE

VEHICLE.

THIS

MANUAL

SHOULD

REMAIN

WITH

THE VEHICLE

THE

TIME

OF RESALE.

INDEX

THE 1982

uLIMITED

WARRANTY

OFTEN

ASKED

QUESTION

. . . . . . . . . . . . . . . . . . . . . . . . . . .

LISTING OF

AREA

DISTRIBUTORS

,.8

HOW

TO IDENTIFY

YOUR

SNOWMOBILE

, ." 9

CONTROLS/INSTRUMENTS

Throttle lever, brake lever, ignition/light switch, high beam indicator, emergency

cut-out switch, headlamp dimmer switch, rewind starter handle, primer, speed-

ometer, tether cut-out switch, oil level indicator, fuel gauge, fuel tank cap, hood

latch, adjustable steering handle, tool box

...

, . . . . . . . . . . . . . . . . .

...

. . .10

BREAK-IN PERIOD

Break-in, inspection! inspection checklist , , 13

FUEL

Recommended gasoline, recommended injection oil 15

PRE-START CHECK

Check

points.

. , ,

,...........

.15

STARTING

PROCEDURE

Manual starting! emergency starting, before

riding.

. . . . . . . . . . .

....

.16

LUBRICATION

Frequency, steering mechanism, chaincase oil level, oil injection system, drive

axle, slide suspension

.17

MAINTENANCE

Belt guard removal, drive belt removal! drive belt condition, new drive belt, drive

pulley! brake condition, brake adjustment, suspension condition, suspension ad-

justment, track condition, track tension and alignment, steering mechanism,

steering adjustment, spark plugs, engine head nuts, engine mount nuts, muffler

attachment, carburetor adjustment, oil injection pump adjustment, fan belt,

headlamp beam aiming! bulb replacement, general inspection .19

STORAGE

Track, suspension! skis, controls, chaincase, fuel tank, carburetor, cylinder lubri-

cation, chassis, general inspection

, . . . . . . .

.28

PRE-SEASON PREPARATION

Pre-seasonpreparation chart " . . . . . . . . . . . . . . . . .

TROUBLE

SHOOTING

GUIDE

TOOLS

, , 34

SPECIFICATIONS , , 35

WIRING

DIAGRAM

, . , , .

. 37

METRIC

INFORMATION

GUIDE

CHANGE

ADDRESS

OWNERSHIP.

.39

LIMITED

WARRANTY

1982

SKI

DOO~

SNOWMOBILES

PERIOD

BOMBARDIER@ INC. as manufacturer, warrants FROM THE DATE OF FIRST

CONSUMER SALES, every 1982

SKI-DOO@

snowmobile, sold as NEW

AND

UN-

USED, by an authorized SKI-DOO dealer,

for

periods of:

• 12 consecutive

months

for

ELAN®,

CITATION*, EVEREST®, ELlTE®,

ALPINE® models.

• 90 consecutive days

for

NORDIK*,

SKANDIC*,

BLiZZARD® 5500

and 9500

models subject to the following:

1. If delivery is made after the 31st day of March

a given year and before the 1st

day of December

the same year, the above 90 day warranty will start on De-

cember 1st.

2. If delivery is made

on/or

after the 2nd day of January

a given year

but

before

the 31st day

March

the same year, all the unused portion

the 90 day pe-

riod will be carried over to the

winter

and start again on the 1st day

De-

cember

the same year.

WHAT

BOMBARDIER. WILL DO

BOMBARDIER will repair

and/or

replace, at its option, components defective in

material

and/or

workmanship (under normal use and servlce.)

with

agenuine

BOMBARDIER component

without

charge

for

parts or labour, at any authorized

SKI-DOO dealer during said warranty period.

CONDITION TO HAVE WARRANTY WORK PERFORMED

Present to the servicing dealer, the hard copy

the BOMBARDIER Customer Re-

gistration card received by the customer

from

the selling dealer at time

pur-

chase.

WARRANTY TRANSFER

This warranty is transferable to subsequent owner(s)

for

remainder of warranty pe-

riod

from

original date of sale.

EXCLUSIONS

ARE NOT WARRANTED

•Normal wear on all items such as,

but

not

limited to:

- drive belts

slider shoes

- spark plugs

-breaker points

-runners on skis

•Replacement parts

and/or

accessories

which

are

not

genuine BOMBARDIER

parts

and/or

accessories.

• Damage resulting

from

installation

parts other than genuine BOMBARDIER

parts.

• Damage caused by failure to provide proper maintenance as detailed in the

Operator Manual. The labour, parts and lubricants costs

all maintenance ser-

vices, including tune-ups and adjustments will be charged to the owner.

• A sulphated battery.

• Vehicles used

for

racing purposes.

• All optional accessories installed on the vehicle.

(The normal warranty policy

for

parts and accessories, if any, applies).

• Damage resulting from accident, fire or other casualty, misuse, abuse or ne-

glect.

• Damage resulting from modification to the snowmobile

not

approved in writing

by BOMBARDIER.

• Losses incurred by the snowmobile owner other than parts and labour, such as,

but

not limited to, transportation, towing, telephone calls, taxis, or any other in-

cidental or consequential damages.

Some states or provinces do not allow the exclusion or limitation

inciden-

tal or consequential damages, so the above limitation or exclusion may not

apply.

6• EXPRESSED OR IMPLIED WARRANTIES

This warranty gives you specific rights, and you may also have other legal

rights which

may

vary from state to state, or province to province. Where

ap-.

plicable this warranty is expressly in lieu of all other expressed or implied

warranties

BOMBARDIER, its distributors and the selling dealer, including

any warranty of merchantability of fitness for any particular purpose; other-

wise the implied warranty is limited to the duration of this warranty.

How-

ever, some states or provinces do not allow limitations on

how

long an im-

plied warranty lasts, so the above limitation may

not

apply.

Neither the distributor, the selling dealer, nor any other person has been

authorized to

make

any affirmation, representation or warranty other than

those contained in this warranty, and if made, such affirmation, representa-

tion or warranty shall not be enforceable against BOMBARDIER or any other

person.

BOMBARDIER INC. reserves the right to modify its warranty policy at any

time, being understood that such modification will not alter the warranty

conditions applicable to vehicles sold while the above warranty is in effect.

7.CONSUMER ASSISTANCE

If a servicing problem or other difficulty occurs, we suggest the following:

1. Try to resolve the problem at the dealership

with

the Service Manager or

Owner.

2. If this fails, contact your area distributor listed in the Operator Manual.

3. Then if your grievance still remains unsolved, you may write to us:

Bombardier Inc.

Service Department

Recreational Products

Valcourt, Quebec, Canada, JOE 2LO

January

1981

Bombardier Inc.

Valcourt, Quebec, Canada, JOE 2LO

"Trademarks of Bombardier Inc.

OFTEN

ASKED

QUESTIONS

Why

rnust my snowmobile be registered?

After

alii

do have my original invoice

proof

of when I purchased my snowmobile.

Your warranty is valid

any authorized dealer

the product. Your regis-

tration is the key element in providing the servicing dealer with the necessary

data to complete warranty claim forms. This information is also used to

notify

owners in the event

asafety recall.

How

do I

know

my vehicle has been registered at the factory?

When you

bought

yoursnowmobile the dealer shouldhave completed,

and

forwarded us the manufacturer's

copy

the Customer Warranty Registra-

tion. YOUR DEALER SHOULD HA VEGIVEN YOU THE

HARD

COPY OF THE

WARRANTY

REGISTRA T/ON FORM.

Q: I

bought

my snowmobile in O'Kinq County

but

Isnowmobile in Washington

County. Can the dealer in Washington County accept to perform warranty

work

on my snowmobile?

Yes,

any

authorizeddealer in North America can perform warranty repairs,

providing the customer warranty reaistretion card is presented.

Q: Where can I find information on the lubrication and maintenance of my

snow-

mobile?

In this Operator Manualprovided with the vehicle

the time

first sale.

Q: Will the entire warranty be void or cancelled, if I do

not

operate or maintain my

new

snowmobile exactly as specified in the Operator's Manual?

The warranty

the

new

snowmobile cannotbe "Voided"

"Cancelled".

However,

aparticular failure is caused by operation

maintenance

other

than is

shown

in the OperatorManual, THA Ttenure

may

not

be coveredunder

warranty. This includes service work performed by the customer, especially

the critical adjustments to ignition, timing, carburation

and

oil

injection/or

oil

mixture.

Would

you give some examples of abnormal use or strain/ neglect or abuse?

These terms are general

and

overlap each

other

in areas. Some specific ex-

amples may include: running the machine

out

oil, chain failure caused by a

lack

lubrication, operating the machine with abroken

damaged

part

which causes

another

part

to fail,

and

so on.

you have

any

specific questions

on operation

maintenance, please

contact

your

dealer

for

advice.

What

costs are my responsibility during the warranty period?

The customer's responsibility includes all costs

normalmaintenance ser-

vices, non-warranty repairs, accidents

and

col/ision damage, as well as oils,

and

spark plugs,

and

incidental or consequential damages costs as explained

in the warranty.

Q: Are

"Genuine"

Bombardier replacement parts used in warranty repairs covered

by warranty?

Yes.

When installed

an authorized dealer,

any

"genuine"

Bombardier

part

used in warranty repairs assumes the remaining warranty that exists on

the machine.

I sell my snowmobile within the warranty period,

will

the

new

owner

qualify

for

the balance

the warranty?

Yes,

provided the

unit

has already been registered with the manufacturer.

Note that the change

ownership card in this manual

should

be completed

and

sent to Bombardier Inc.

How

can I receive the best owner assistance?

The satisfaction

and

goodwill

the owners

Bombardierproductsare

primary concern to

your

dealer

and

Bombardier Inc. Normally, any problems

that

arise in connection with the sales transaction

the operation

your

snowmobile

will

be handledby your Dealers Sales

Service Departments. It

is recognized, however,

that

despite the best intentions

everyone concern-

ed, misunderstandings

will

sometimes occur.

you have a problem that has

not

been handled to your satisfaction through normal channels, we suggest

that you discuss yourproblem with amember

dealership management. Fre-

quently, complaints are the result

abreakdown in communications

and

can

quickly be resolved

member

the dealership management.

the prob-

lem already has been reviewed with the Sales Manager

Service Manager,

contact

the Dealer

himself

the General Manager.

LISTING OF AREA DISTRIBUTORS

CANADIAN

DISTRIBUTORS

ALPINE DISTRIBUTORS LIMITED

Kalamalka Lake Road

P.O. Box 159

Vernon, British Columbia,

T 6M2

(604) 545-1314

British Columbia

BOMBARDIER INC.

EASTERN

CANADA

DISTRIBUTION

DIVISION

Atlantic

Branch

P.O. Box 670

Shediac,

New

Brunswick,

EOA

3GO

(506) 532-4454

Magdalen Island, Nova Scotia, New

Brunswick, Prince Edward Island

BOMBARDIER INC.

EASTERN

CANADA

DISTRIBUTION

DIVISION

(Quebec Branch)

1350 Nobel Boulevard

Boucherville, Quebec, J4B 1A1

(514) 527-2469 or 655-6121

Province of Quebec

BOMBARDIER INC.

EASTERN

CANADA

DISTRIBUTION

DIVISION

Ontario Branch

230 Bayview Drive

Barrie, Ontario, L4N 4Y8

(705) 728-8600

Province of Ontario

BROOKS EQUIPMENT LIMITED

1616 King Edward Street

P.O. Box 985

Winnipeg, Manitoba, R3C 2V8

(204) 633-7247

Manitoba, Saskatchewan

HUDSON'S

BAY CO. LTD.

165 Hymus Blvd

Pointe-Claire, Quebec,

M4W

1A8

(514) 697-8500

North-West Territories, Franklin

District & Keewatin

J.W.

RANDALL

LIMITED

West Street

P.O.

Box 1050

Corner Brook, Newfoundland, A2H 6G7

(709) 634-3533

Newfoundland, Labrador

TRACT EQUIPMENT

14325, 114th Avenue

Edmonton, Alberta, T5M 2Y8

(403) 452-9910

Alberta, Dist. Mackenzie, Yukon,

N.W.T.

AMERICAN DISTRIBUTORS

BOMBARDIER CORPORATION

4505

West

Superior Street

P.O. Box 6106

Duluth, Minnesota 55806

(218) 628-2881

North Dakota, Minnesota, Wisconsin,

Illinois, Missouri, Michigan, Indiana,

Ohio (less eastern half), Tennessee,

Kentucky, West Virginia, Virginia,

Northern Idaho, Northern Wyoming,

Montana, Iowa, Washington.

ELLIOTT &HUTCHINS INC.

East Main Street Road

Malone,

New

York 12953

(518) 483-4411

New York, Massachusetts, Connec-

ticut, Rhode Island, Pennsylvania,

New Jersey, Maryland, Delaware,

District of Columbia, Eastern half of

Ohio, Maine, New Hampshire, Vermont.

MILLER EQUIPMENT

AND

RECREATIONAL CENTER

1049

Whitney

Road

Anchorage, Alaska

99501

(907) 274-9513

Alaska

Inhaltsverzeichnis

Andere Ski-Doo Schneemobil Handbücher

Ski-Doo

Ski-Doo Tundra II LT 1997 Installationsanleitung

Ski-Doo

Ski-Doo REV Series Handbuch

Ski-Doo

Ski-Doo 861 002 700 Bedienungsanleitung

Ski-Doo

Ski-Doo REV GEN4 Handbuch

Ski-Doo

Ski-Doo Skandic WT 2013 Handbuch

Ski-Doo

Ski-Doo Tundra II LT 1998 Installationsanleitung

Ski-Doo

Ski-Doo OLYMPIQUE 300 Bedienungsanleitung

Ski-Doo

Ski-Doo REV series 2007 Bedienungsanleitung

Ski-Doo

Ski-Doo NORDIK Bedienungsanleitung

Ski-Doo

Ski-Doo REV GEN4 Handbuch

Ski-Doo

Ski-Doo NORDIK 50 1988 Bedienungsanleitung

Ski-Doo

Ski-Doo MX Bedienungsanleitung

Ski-Doo

Ski-Doo Safari 1990 Bedienungsanleitung

Ski-Doo

Ski-Doo Grand Touring 500 1998 Installationsanleitung

Ski-Doo

Ski-Doo MX Z 440 Installationsanleitung

Ski-Doo

Ski-Doo FORMULA III 1997 Installationsanleitung

Ski-Doo

Ski-Doo 1978 Blizzard Bedienungsanleitung

Ski-Doo

Ski-Doo REV Series Installationsanleitung

Ski-Doo

Ski-Doo CK3 Series 2002 Handbuch

Ski-Doo

Ski-Doo 850 Silber Bedienungsanleitung

Ski-Doo

Ski-Doo Grand Touring 700 2000 Installationsanleitung

Ski-Doo

Ski-Doo 1980 citation 3500 Bedienungsanleitung

Ski-Doo

Ski-Doo Blizzard 5500 1979 Bedienungsanleitung

Ski-Doo

Ski-Doo MXZ 120 2024 Handbuch

Beliebte Schneemobil Handbücher anderer Marken

BRP

BRP Ski-Doo MXZ 120 2023 Bedienungsanleitung

Arctic Cat

Arctic Cat ZR 900 Series 2006 Bedienungsanleitung

Arctic Cat

Arctic Cat Wildcat EFI Mountain Cat 1994 Bedienungsanleitung

BOMBARDIER

BOMBARDIER Ski-Doo Alpine 74 1959 Bedienungsanleitung

Arctic Cat

Arctic Cat Cougar Bedienungsanleitung

Yamaha

Yamaha SnoScoot SXR2NJ Bedienungsanleitung

Yamaha

Yamaha VX500XTB Bedienungsanleitung

Yamaha

Yamaha RS VENTURE 2014 Bedienungsanleitung

Polaris

Polaris RMK Shift Bedienungsanleitung

Yamaha

Yamaha VK540EF Bedienungsanleitung

Yamaha

Yamaha VK540EF Bedienungsanleitung

BOMBARDIER

BOMBARDIER ski-doo Nordic 640ER 1974 Bedienungsanleitung

BOMBARDIER

BOMBARDIER ski-doo OLYMPIQUE 300 1974 Bedienungsanleitung

Yamaha

Yamaha SXV4NP Bedienungsanleitung

Ohlins

Ohlins PB 616 Bedienungsanleitung

Polaris

Polaris 600 RUSH 2013 Leitfaden

BOMBARDIER

BOMBARDIER Ski-doo MX ZX 440 Handbuch

Polaris

Polaris 600 INDY VOYAGEUR Bedienungsanleitung