Town & Country Fireplaces TC54 SERIES DMODULAR Bedienungsanleitung

SKU# 22150048

For TC54 Series D

Fireplaces

These instructions are supplementary to the Installation and

Operating Instructions supplied with the replace and should

be kept together. Refer to the Installation and Operating

Instructions for proper gas supply, safety requirements and

operating instructions.

TC54

BLACK DIAMOND

BURNER KIT

INSTRUCTIONS

270223-20 SKU# 22150048 100005914

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

AMANIFOLD ASSEMBLY

(Including supply tube)

BBURNER TUBE, FRONT

CBURNER TUBE, REAR

DBURNER SHIELD

EMEDIA SPACER, Rr Center

FMEDIA SPACER, Fr Center

GMEDIA SPACER, Front

HMEDIA SPACER, Rear

IMEDIA SPACER, Left

JMEDIA SPACER, Right

KHARDWARE PACKAGE

L5 lbs. GLASS MEDIA

MBURNER TRAY

NPILOT

Figure 1: TC54 Black Diamond burner kit contents.

SKU# 22150048_270223-20

100005914

Package Contents

1. Remove one screw from the center rear of the rebox and use it to attach the manifold assembly.

(Figure 2)

2. Remove the 2 screws from the rebox bottom. (Figure 4)

3. Attach the manifold supply tubes from the “T” to the ttings on the two manifolds(Figure 3)

NOTE:

If unit is to be converted to Propane, see Propane conversion instructions on page 13 before

proceeding.

The panel set instructions must be used when installing this burner. Typically all panels except the

right side should be installed prior to burner installation.

NOTE: Plug the 4 vacant holes in the bottom of the ﬁrebox with #8x1/2” screws.

The holes are not required for this style of burner.

SCREWS

Figure 2: TC54 Black Diamond burner kit contents.

Figure 3: Attach main gas supply tubes from the “T” to manifolds.

Figure 4: Screws in oor.

SKU# 22150048 270223-20 3100005914

Black Diamond Burner Installation

Figure 5: Remove access panel.

Interface module

Figure 6: Attach gas supply tubes to bulkhead

4. Remove access cover to the valve control center from the right side of the re box (Figure 5).

5. Attach the center supply tube from the “T” and the pilot gas supply tube to the bulk head tting and

tighten (Figure 6).

SKU# 22150048_270223-20

100005914

Ignition and sensor wires

Bulkhead plate

Figure 7: Remove access panel.

Ignition wire (red)

Flame sensor

wire (white)

Interface module

Figure 8: Interface module.

6. Feed the ignition and sensor wires through the bulkhead plate to the interface module.

(Figure 7).

7. Attach the ignition and sensor wires to the interface module as shown in (Figure 8).

SKU# 22150048 270223-20 5100005914

Figure 9: Replace access panel.

Figure 10: Install shield.

8. Re-install the access panel in the right side of the rebox (Figure 9).

9. Place burner shield into unit, exing right shield leg slightly to clear manifold. Make sure the pilot

protrudes through the center hole. (Figure 10).

NOTE: The shield sits at an approximately 15 degree angle to the base of the ﬁrebox.

SKU# 22150048_270223-20

100005914

Figure 11: Attach pilot.

Figure 12: Install front media spacer.

10. Cover the glossy surface of the burner shield to prevent surface damage while connecting pilot to

the underside of the burner tray. (Figure 11)

NOTE: Start screws with ngers rst to prevent cross-threading.

11. Place front media spacer into the front of the tray. (Figure 12)

SKU# 22150048 270223-20 7100005914

Figure 13: Installing front burner.

Figure 14: Burner tube placement

11. Install front burner tube by tilting it into the front tray hole until almost fully seated. (Figure 13)

Set the air shutter to fully open for Propane or fully closed for Natural gas.

12. Guide tray and burner tube back until the burner tube engages the forward orice. This can be

seen through the rear burner hole. (Figure 14)

SKU# 22150048_270223-20

100005914

13. Attach burner tray to shield with four screws. (Figure 15)

14.The rear media spacer is now installed. (Figure 16)

Figure 15: Attach tray to shield.

Figure 16: Rear media spacer.

SKU# 22150048 270223-20 9100005914

14. Install rear burner by tilting the inlet through the rear hole in the tray. Engage the inlet with the rear

orice. This can be seen from the back of the tray.(Figure 17)

Set the air shutter to fully open for Propane or fully closed for Natural gas.

15. Install center media spacers and screw down through burner and tray with 1 1/2” screws. (Figure

18). Three holes must line up to set each screw.

Figure 17: Install Rear burner.

Figure 18: Center media spacers.

SKU# 22150048_270223-20

100005914

Andere Handbücher für TC54 SERIES DMODULAR

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Town & Country Fireplaces Kamin im Innenbereich Handbücher

Town & Country Fireplaces

Town & Country Fireplaces TCWS54DST Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.CSTE3 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCW120 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS38 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.38NG03.C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54 SERIES D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces Architectural Series Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36AR Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces D Series Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.CE3 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC54.NG03C2 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36ST Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54OD Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54CSTE Betriebsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC54.CE2 Series C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30D2 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54CE3 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch