Kohler K-3593 Bedienungsanleitung

Installation Guide

Kitchen Sinks

Mproduct numbers are for Mexico (i.e. K-12345M)

Los números de productos seguidos de Mcorresponden a México

(Ej. K-12345M)

Français, page ″Français-1″

Español, página ″Español-1″

K-3593

1068810-2-A

Thank You For Choosing Kohler Company

We appreciate your commitment to Kohler quality. Please take a few minutes to review this manual before

you start installation. If you encounter any installation or performance problems, please don’t hesitate to

Company.

Tools and Materials

Important Information

WARNING: Risk of personal injury. Metal surfaces are sharp and can cause severe cuts. Use

gloves and handle sink edges carefully.

CAUTION: Risk of personal injury or product damage. Large sinks are very heavy. Get help

lifting the sink into place.

IMPORTANT! Your sink may appear different than the sink pictured throughout the installation steps.

For ease of installation, two people should perform this installation.

Due to the nature of undercounter installations, Kohler Co. recommends that undercounter sink

installations be performed by trained and experienced installers.

For sinks with drawer system: Order additional drawer hardware for the sink cabinet drawer

panels.

A 1-1/2″(3.8 cm) to 2″(5.1 cm) thick countertop is preferred for this installation.

Anchors should be preinstalled by the countertop manufacturer at the time of cutting. Use the

hardware provided by the countertop manufacturer and the mounting clips provided with your

sink.

The number of clips included with your sink may differ from the number of clips illustrated. Use all

clips included with the sink.

If possible, install the strainer to the sink prior to installing the sink.

Allow the sealant to cure following the sealant manufacturer’s instructions.

Observe all local plumbing and building codes.

All information in these instructions is based on the latest product information available at the time

of publication. Kohler Co. reserves the right to make revisions in the design of products without

notice, as speciﬁed in the Price Book.

Silicone Sealant

Plumbers Putty

Plus:

• Double-Sided Tape

(optional)

1068810-2-A 2 Kohler Co.

1. Prepare the Site

For ease of sink installation, remove the cabinet doors and the drawer panel that corresponds to the

sink drawer installation location.

Install the water supplies and drain piping according to the roughing-in information.

Install the countertop.

Remove the

cabinet doors.

Remove the drawer front

that corresponds to the

drawer location on the sink.

Kohler Co. 3 1068810-2-A

2. Install the Drawer Slides

The drawer slides can be installed to the sink prior to the sink installation in cabinets with speciﬁc front rail

and drawer opening dimensions. If your cabinet has dimensions other than those listed in the table above,

the drawer slides will be installed later in the ″Install the Drawer″section.

Measure the height of the front rail of the cabinet.

If the front rail height is not 11/16″(1.7 cm) or 1-1/2″(3.8 cm), proceed to the ″Install the Sink″

section.

Determine Slide Placement

If the front rail height is 11/16″(1.7 cm) and the drawer opening height is 5″(12.7 cm), then loosely

secure the drawer slide to slot 1.

If the front rail height is 1-1/2″(3.8 cm) and the drawer opening height is 5″(12.7 cm), then loosely

secure the drawer slide to slot 2.

Install the Slides

NOTE: Slides may need to be extended to allow access to the slide mounting holes.

Attach the slides to the bracket using the screws. Position the screws through the appropriate slot.

Loosely secure the slides to the brackets with the washers and nuts.

Close the slide assemblies. You may need to pull the screws to allow the slide assembly to close.

Refer to illustration 5in the ″Install the Drawer″section.

Measure height

of front rail. Measure height of the drawer opening.

Slot 1

Slot 2

Front Rail

Height

11/16" (1.7 cm)

1-1/2" (3.8 cm)

Drawer

Opening Height

5" (12.7 cm)

Slot

Drawer

Slide

Bracket

1068810-2-A 4 Kohler Co.

3. Install the Sink

Using the hardware provided by the countertop manufacturer, loosely attach the mounting clips to

the underside of the countertop.

Turn all the mounting clips parallel to the countertop opening.

Apply a bead of silicone sealant around the top edge of the sink rim.

Maneuver the sink into the cabinet and lift into position.

Turn all the mounting clips to hold the sink in place.

Center the sink and secure by tightening all the mounting clips.

Loosely attach the

mounting clips.

Apply silicone sealant

to the sink rim.

Secure the sink.

Kohler Co. 5 1068810-2-A

4. Install the Drawer

If the slides are already installed, proceed to the ″Complete the Drawer Installation″section.

Insert the drawer assembly into the cabinet opening and hold in position.

Position the drawer so that it will clear the cabinet when opened. Note the slot that aligns with the

holes in the slide.

Remove the drawer from the opening.

Remove the slides from the drawer.

NOTE: Slides may need to be extended to allow access to the slide mounting holes.

Insert the screws through the slide and the appropriate slot in the brackets.

Loosely secure the slides to the brackets with the washers and nuts.

Close the slide assemblies. You may need to pull the screws to allow the slide assembly to close.

Note the slot and

hole alignment.

Loosely thread the nuts to the screws.

Insert the drawer

and hold in position.

Remove the

drawer slides.

Slide

Assembly

Bracket

Screw

Head

Pull screw to

allow the slide

assembly to

close.

Drawer

Slide

Bracket

Slot

Hole

Slide Track

Nut

Bracket

Screw

Washer

1068810-2-A 6 Kohler Co.

5. Complete the Drawer Installation

Types of Drawer Panels

Overlay Panels: Panels rest on the surface of the cabinet frame.

Inset Panels: Panel face sits ﬂush with the front of the cabinet frame.

Install the Drawer

For overlay drawer panels: Position the slides ﬂush with the cabinet face.

For inset drawer panels: Position the slides ﬂush with the inside of the cabinet.

Securely tighten the nuts to secure the slides.

Reinstall the drawer onto the slides. Press ﬁrmly to fully seat the drawer back onto the slides.

Position the slides

flush with the

cabinet face.

Position the slides

flush with the inside

of the cabinet.

Overlay Drawer Panel

Inset Drawer Panel

Kohler Co. 7 1068810-2-A

6. Complete the Installation

If you are installing drawer pulls, install them to the drawer panels at this time.

Optional: Apply double-sided tape (not provided) to the drawer face to help hold the drawer panel

in position.

Loosely attach the drawer panel using a screw and the large washer through the center hole of the

drawer.

Adjust the drawer panel as needed and securely tighten the screw.

Secure the drawer panel with the additional four screws and small washers.

Install the faucet and strainers according to the instructions packed with the products.

Complete the faucet and drain connections.

Run water into the sink and check all connections for leaks.

Reinstall the cabinet doors.

Affix drawer face with

double-sided tape.

Large

Washer

Small

Washer

Reinstall the

cabinet doors.

1068810-2-A 8 Kohler Co.

Guide d’installation

Éviers de cuisine

Outils et matériels

Merci d’avoir choisi la compagnie Kohler

Nous apprécions votre engagement envers la qualité Kohler. Veuillez prendre s’il vous plaît quelques

minutes pour lire ce manuel avant de commencer l’installation. Ne pas hésiter à nous contacter en cas de

problème d’installation ou de performance. Nos numéros de téléphone et notre adresse du site internet sont

au verso. Merci encore d’avoir choisi la compagnie Kohler.

Renseignements importants

AVERTISSEMENT : Risque de blessures corporelles. Les surfaces métalliques ont des bords

tranchants et peuvent engendrer de graves coupures. Porter des gants et manipuler les bords de

l’évier avec précaution.

ATTENTION : Risque de blessure corporelle ou d’endommagement du produit. Les éviers larges

sont très lourds. Demander de l’aide pour soulever et mettre en place l’évier.

IMPORTANT ! L’évier actuel pourrait différer de celui illustré dans les étapes d’installation.

Pour une facilité d’installation, deux personnes devraient effectuer cette installation.

Vu la nature particulière des installations sous comptoir, Kohler Co. recommande que les

installations des éviers sous comptoir soient effectuées par des installateurs formés et expérimentés.

Pour des éviers à système de tiroir: Commander de la boulonnerie supplémentaire de tiroir pour

les panneaux du tiroir du meuble.

Un comptoir d’une épaisseur de 1-1/2″(3,8 cm) à 2″(5,1 cm) est préférable pour cette installation.

Des ancrages devraient être préalablement installés par le fabricant du comptoir au moment de la

découpe. Utiliser la boulonnerie fournie par le fabricant du comptoir et les clips de ﬁxation fournis

avec l’évier.

Le nombre de clips inclus avec l’évier pourrait différer du nombre illustré. Utiliser tous les clips

inclus avec l’évier.

Mastic à la

silicone

Mastic de

plombier

Plus:

• Ruban adhésif double face

(optionnel)

Kohler Co. Français-1 1068810-2-A

Renseignements importants (cont.)

Si possible, installer la crépine sur l’évier avant d’installer ce dernier.

Laisser prendre le mastic selon les instructions du fabricant.

Respecter tous les codes de plomberie et de bâtiment locaux.

Toutes les informations contenues dans ces instructions sont basées sur les données les plus récentes

relatives au produit au moment de la publication. Kohler Co. se réserve le droit d’apporter toutes

modiﬁcations sur le design des produits et ceci sans préavis, tel que spéciﬁé dans le catalogue des

prix.

1068810-2-A Français-2 Kohler Co.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Sprachen:

Andere Kohler Sanitärprodukte Handbücher

Kohler

Kohler Rada Intelligent Care MX1 20 Bedienungsanleitung

Kohler

Kohler K-702200 Montageanleitung

Kohler

Kohler WELLINGTON WATERGUARD K-3415 Bedienungsanleitung

Kohler

Kohler Escale 19046W Bedienungsanleitung

Kohler

Kohler 11829T-B Bedienungsanleitung

Kohler

Kohler K-702200 Bedienungsanleitung

Kohler

Kohler K-5329 Montageanleitung

Kohler

Kohler ENGLEFIELD CORNER CONTOUR PLUS Bedienungsanleitung

Kohler

Kohler K-1517 Bedienungsanleitung

Kohler

Kohler Loure T97330-4-CP Bedienungsanleitung

Kohler

Kohler Flipside 17492T Bedienungsanleitung

Kohler

Kohler ALTERNA Bedienungsanleitung

Kohler

Kohler K-994 Bedienungsanleitung

Kohler

Kohler K-4108 Bedienungsanleitung

Kohler

Kohler K-14620 Montageanleitung

Kohler

Kohler K-7303 Bedienungsanleitung

Kohler

Kohler K-2268 Bedienungsanleitung

Kohler

Kohler MAXISPACE 2.0 K-24369X Bedienungsanleitung

Kohler

Kohler K-7322 Bedienungsanleitung

Kohler

Kohler Candide 7688K-4E3 Bedienungsanleitung

Kohler

Kohler K-4000 Montageanleitung

Kohler

Kohler HARTLAND K-11021T-1S Bedienungsanleitung

Kohler

Kohler K-6284-NA Montageanleitung

Kohler

Kohler Stance 14775-4-CP Montageanleitung

Beliebte Sanitärprodukte Handbücher anderer Marken

Weka

Weka 506.2020.00E Betriebsanleitung

American Standard

American Standard DetectLink 6072121 Bedienungsanleitung

Uponor

Uponor Contec TS Bedienungsanleitung

Pfister

Pfister Selia 49-SL Bedienungsanleitung

Fortis

Fortis VITRINA 6068700 Bedienungsanleitung

Maxxus

Maxxus MX-M206-01 Bedienungsanleitung

Viega

Viega Prevista Pure 8512 Bedienungsanleitung

Viega

Viega Prevista Dry 8522.33 Bedienungsanleitung

Sanela

Sanela Lema SLP 59RB Bedienungsanleitung

Elkay

Elkay EDF15AC Installationshandbuch

Hans Grohe

Hans Grohe AXOR Citterio E 36702000 Handbuch

baliv

baliv WT-140 Bedienungsanleitung

BELLOSTA

BELLOSTA romina 0308/CC Bedienungsanleitung

Bristan

Bristan PS2 BAS C D2 Verdrahtungsschema

Crosswater

Crosswater Heir 18-31 Bedienungsanleitung

Sanela

Sanela SLVN 07 Bedienungsanleitung

Glacier bay

Glacier bay DORIND HD67478W-6001 Montageanleitung

Sterling Plumbing

Sterling Plumbing C741 Bedienungsanleitung