Mercia Garden Products 01DTOVPN0806SDFW-V1 Gebrauchsanweisung

**Protim Aquatan T5 (621)**

Your building has been dip treated with Aquatan.

Aquatan is a water-based concentrate which is diluted with water, the building has been treated by the

correct application of Aquatan solution and then allowed to dry.

Aquatan is a decorative nish to colour the wood, which is applied industrially to timber fence panels and

garden buildings.

Aquatan undiluted contains: boric acid, sodium hydroxide 32% solution, aqueos mixture of sodium dioctyl

sulphosuccinat and alcohols: 2, 4, 6-trichlorophenol.

Measure

under the

head

Measure

overall

length

Screws & Nails Bolts To identify the

xings required

for each step use a

measuring tape.

01DTOVPN0806SDFW-V1

DIP TREATED OVERLAP PENT 8X6 SINGLE DOOR FIXED WINDOW

2mm Drill bit

x2 Winter = High Moisture = Expansion

Summer = Low Moisture = Contraction

All buildings should be

erected by two adults

For ease of assembly, you

MUST pilot drill all screw

holes and ensure all screw

heads are countersunk.

For assistance please contact customer care on: 01636 821215

Mercia Garden Products Limited,

Sutton On Trent,

Newark,

Nottinghamshire,

NG23 6QN

www.merciagardenproducts.co.uk

CAUTION

Every eort has been made during the

manufacturing process to eliminate the

prospect of splinters on rough surfaces of the

timber. You are strongly advised to wear gloves

when working with or handling rough sawn

timber.

BEFORE YOU START PLEASE READ INSTRUCTIONS CAREFULLY

- Check the pack and make sure you have all the parts listed.

- When you are ready to start, make sure you have the right tools at hand (not supplied) including a Phillips screw-

driver, Stanley knife, Wood saw, Step ladder, Hammer and a Drill with 2mm bit.

- Ensure there is plenty of space and a clean dry area for assembly.

LOCATION FOR YOUR GARDEN BUILDING

A minimum of 60cm should be left around the perimeter of your garden building to allow access for maintenance,

annual treatment and to allow air ow around the building.

Where possible you should avoid placing your garden building underneath large trees to prevent the tree causing

damage to the building.

TIMBER

As with all natural materials, timber can be aected during various weather conditions. For the duration of heavy

or extended periods of rain, swelling of the wood panels may occur. Warping of the wood may also occur during

excessive dry spells due to an interior moisture loss. Unfortunately, these processes cannot be avoided but can be

helped. It is suggested that the outdoor building is sprayed with water during extended periods of warm sunshine

and sheltered as much as possible during rain or snow.

Once your garden building has been installed it will need to be treated as soon as possible and annually to prevent

the timber from deteriorating and to waterproof it. This is required to maintain the anti-rot guarantee.

Dip Treated buildings - Require a preservative treatment to protect against rot and decay and a waterproof treat-

ment to prevent water ingress

Pressure Treated buildings - Require a waterproof treatment to prevent water ingress

Log Cabins - Are supplied untreated and require a preservative and waterproong treatment.

BUILDING A BASE

When thinking about where the building and base is going to be constructed:

Ensure that there will be access to all sides for maintenance work and annual treatment.

Ensure the base is level and is built on rm ground, to prevent distortion. Refer to diagrams for the base

dimensions, The base should be slightly smaller than the external measurement of the building, i.e. The cladding

should overlap the base, creating a run o for water. It is also recommended that the oor be at least 25mm above

the surrounding ground level to avoid ooding.

TYPES OF BASE

- Concrete 75mm laid on top of 75mm hard-core.

- Slabs laid on 50mm of sharp sand.

Whilst all products manufactured are made to the highest standards of Safety and in the case of childrens

products independently tested to EN71 level, we cannot accept responsibility for your safety whilst erecting or

using this product.

For ease of assembly, you

will need a tape measure to

check dimensions of

components.

ANTI-ROT

GUARANTEE TODAY

PLEASE SCAN HERE:

P 1

Please retain product label and instructions for future reference

General Instructions

P 2

01DTOVPN0806SDFW-V1

Overall Dimensions:

Width = 2410mm

Depth = 1890mm

Height = 2014mm

Base Dimensions:

Width = 2350mm

Depth = 1753mm

Please retain product label and instructions for future reference

Before assembly

please make sure you have a

suitable base ready to erect your

building

MADE IN GREAT BRITAIN

Door Panel QTY 1

AI-01R11OVSD1180X1972-V1

Window Panel QTY 1

AI-01R11OV2CW1180X1972-V1

Right Gable QTY 1

AI-01R11OVLPGR1707X1980-V1

Left Gable QTY 1

AI-01R11OVLPGL1707X1980-V1

Plain Panel QTY 2

AI-R11OVPP1180X1799-V1

Floor QTY 2

AI-R11OSBF1175X1753-V1

Roof QTY 3

PI-03-0259

Door QTY 1

AI-R11FBMBZBD661X1780-V1

Ridge Bar 27x44x1712mm QTY 2

F2744-1712mm

Door Block 28x28x150mm QTY 1

F2828-150mm

Eaves Framing 28x28x795mm QTY 6

F2828-795mm

12 Window Strips 12x28x580mm QTY 4

S1228-580mm

Window Cover Trims 12x40x518mm QTY 3

S1240-518mm

Window Cover Trim 12x40x1180mm QTY 1

S1240-1180mm

15 Back Cover Trims 12x40x1798mm QTY 3

S1240-1798mm

16 Front Cover Trims 12x40x1970mm QTY 3

S1240-1970mm

17 Fascias 12x60x1205mm QTY 4

S1260-1205mm

18 Fascias 12x60x1870mm QTY 2

S1260-1870mm

Styrene QTY 2

PI-05-0114

Window Cill QTY 1

PI-08-0001

Turn Button QTY 2

PI-07-0034

Hasp and Staple QTY 1

PI-07-0207

Felt QTY 1

PI-01-0013

T-Hinge QTY 3

PI-07-0021

Door Beading Strip 12x28x1720mm QTY 2

S1228-1720mm

Nail Bag

There may be extra screws present in the nail bag

21 22

23 24 25

50mm Screw x 28

40mm Screw x 24

Felt Tacks x 110

20mm Screw x 3

30mm Screw x 142

60mm Screw x 4

P 3

Please retain product label and instructions for future reference

Pre Assembly

Before assembling remove the transportation

blocks from the bottom of each panel.

Take care removing the blocks as to not damage

the panels. Tap with a at headed screwdriver

and hammer.

Dispose of the blocks once removed.

Pre drill

hole

IMPORTANT: Pre-drill before xing screws.

Step 1

Parts needed - No. 6 QTY 2

Place the oor panels (No.6) onto a rm

and level base. Ensure the base has suitable

drainage, free from areas where standing

water can collect.

Secure the oors together using 8x50mm

screws through the oor bearers in an

alternating pattern.

8x50mm Screws

50mm

screw

IMPORTANT: Pre-drill before xing screws.

Step 2

Parts needed - No. 1 QTY 1

No. 8 QTY 1

No. 25 QTY 3

Place the door (No.8) within the

Door Panel (No. 1). Fix the T Hinges

(No. 25) onto the door and Door

Panel as shown (taking into account

on which side of the Door Panel

opening you want the Door to open).

Ensure that the screws go through the

cladding and into the framing behind.

21x30mm Screws

Pre drill

hole

30mm

screw

Opens from the Left Opens from the Right

**PLEASE NOTE** Before tting the

hinges, ensure the door is in the correct

position depending on which side you

want the door to open. See external

illustrations below which show the doors

internal framing.

265

P 4

For assistance please contact customer care on: 01636 821215

Mercia Garden Products Limited,

Sutton On Trent,

Newark,

Nottinghamshire,

NG23 6QN

www.merciagardenproducts.co.uk

BEFORE YOU START PLEASE READ INSTRUCTIONS CAREFULLY

- Check the pack and make sure you have all the parts listed.

- When you are ready to start, make sure you have the right tools at hand (not supplied) including a Phillips screw-

driver, Stanley knife, Wood saw, Step ladder, Hammer and a Drill with 2mm bit.

- Ensure there is plenty of space and a clean dry area for assembly.

LOCATION FOR YOUR GARDEN BUILDING

A minimum of 60cm should be left around the perimeter of your garden building to allow access for maintenance,

annual treatment and to allow air ow around the building.

Where possible you should avoid placing your garden building underneath large trees to prevent the tree causing

damage to the building.

TIMBER

As with all natural materials, timber can be aected during various weather conditions. For the duration of heavy

or extended periods of rain, swelling of the wood panels may occur. Warping of the wood may also occur during

excessive dry spells due to an interior moisture loss. Unfortunately, these processes cannot be avoided but can be

helped. It is suggested that the outdoor building is sprayed with water during extended periods of warm sunshine

and sheltered as much as possible during rain or snow.

Once your garden building has been installed it will need to be treated as soon as possible and annually to prevent

the timber from deteriorating and to waterproof it. This is required to maintain the anti-rot guarantee.

Dip Treated buildings - Require a preservative treatment to protect against rot and decay and a waterproof treat-

ment to prevent water ingress

Pressure Treated buildings - Require a waterproof treatment to prevent water ingress

Log Cabins - Are supplied untreated and require a preservative and waterproong treatment.

BUILDING A BASE

When thinking about where the building and base is going to be constructed:

Ensure that there will be access to all sides for maintenance work and annual treatment.

Ensure the base is level and is built on rm ground, to prevent distortion. Refer to diagrams for the base

dimensions, The base should be slightly smaller than the external measurement of the building, i.e. The cladding

should overlap the base, creating a run o for water. It is also recommended that the oor be at least 25mm above

the surrounding ground level to avoid ooding.

TYPES OF BASE

- Concrete 75mm laid on top of 75mm hard-core.

- Slabs laid on 50mm of sharp sand.

Whilst all products manufactured are made to the highest standards of Safety and in the case of childrens

products independently tested to EN71 level, we cannot accept responsibility for your safety whilst erecting or

using this product.

Please retain product label and instructions for future reference

IMPORTANT: Pre-drill before xing screws.

Step 3

Parts Needed - No.4 QTY 1

- No.5 QTY 2 5

Place the Left Gable (No.4) and the Plain

Panel (No.5) onto the oor. Secure the

gable to the plain panel at the corner

using 3x50mm screws.

Fix the second Plain Panel (No.5) to the

rst using 3x50mm screws in an

alternating pattern

Do not secure the building to the oor

until the roof is tted.

Position the panels so there is equal

spacing between the oor and cladding

6x50mm Screws

50mm

screw

Pre drill

hole

IMPORTANT: Pre-drill before xing screws.

Step 4

Parts Needed - No.2 QTY 1

- No.3 QTY 1

Place the Window Panel (No.2) and the Right

Gable (No.3) onto the oor, secure at the

corners using 3x50mm screws per corner.

Do not secure the building to the oor until

the roof is tted.

Position the panels so there is equal spacing

between the oor and cladding

6x50mm Screws

50mm

screw

Pre drill

hole

**Please note: the front panels are

interchangable and can be

positioned on either side of the

building. Decide which works best

before assembly**

IMPORTANT: Pre-drill before xing screws.

Step 5

Parts Needed - No.1 QTY 1

Place the Door panel (No.1) onto

the oor and x at the corner

using 3x50mm screws. Fix the

Door panel to the Window panel

using 3x50mm screws in an

alternating pattern.

Do not secure the building to the

oor until the roof is tted.

Position the panels so there is

equal spacing between the oor

and cladding

6x50mm Screws

50mm

screw

Pre drill

hole

IMPORTANT: Pre-drill before xing screws.

Step 6

Parts needed - No.9 QTY 2

Pre drill

hole

30mm

screw

Align the ridge bars (No.9) between

the front and back of the building,

732mm from the gable to the ridge

bar. Secure 2x60mm screws per

Ridge bar, ensuring to go through

the panel framing and into the ridge

bar.

*Ensure the ridge bar is ush with

the top framing of the gable tops.

4x60mm Screws

732mm 732mm

P 5

Please retain product label and instructions for future reference

Step 7

Parts Needed - No.7 QTY 3

- No.11 QTY 6

Fix the Eaves framing (No.11) to

the roof sheets (No.7) using

3x30mm screws per eaves frame.

The framing should nish ush

with the edge of the roof sheet

18x30mm Screws

30mm

screw

Pre drill

hole

IMPORTANT: Pre-drill before xing screws.

Step 8

Parts Needed - No.7 QTY 3

Fix the roof panels onto the top of

the building using 26x30mm

screws, ensuring to be ush on

the sides and equal spacing at the

front and back of the building

26x30mm Screws

IMPORTANT: Pre-drill before xing screws.

Step 9

40mm

screw

Pre drill

hole

IMPORTANT: Pre-drill before xing screws.

bbbbbbbbb

Fix the building to the oor

using 24x40mm screws,

ensuring to go through the

panel framing and into the

oor

24x40mm Screws

P 6

Please retain product label and instructions for future reference

HANDLE

WITH CARE

Step 10

Parts Needed - No.24 QTY 1

IMPORTANT: Pre-drill before xing screws.

Cut the felt (No.24) into 2 sheets of

2480mm and lay onto roof as

shown in diagram ensuring there is

a 50mm overhang around each

side. Nail using felt tacks

110xFelt tacks

IMPORTANT: Pre-drill before xing screws.

Fix 4x Window strips (No.12) to the framing

along the outside edge of the window gap using

3x30mm screws per strip.

Place the Plastic cill (No.21) into the window

panel as shown in the illustration. Fix to

framing using 3x20mm screws

Fit the Styrene sheets (No.20) on top of the

window cill.

*For added weather protection t your

windows using silicone sealant around

the outside edges.

**When positioning the styrene sheets ensure

there is an equal distance on all sides.

Attach the 4x Window Cover trims (No.13 and

No.14) to either side of the windows and the

centre. Secure into place using 3x30mm

screws per strip.

3x20mm Screws

24x30mm Screws

Pre drill

hole

20mm

screw

Styrene

Window Cill

Cladding

Side View

Step 11

Parts Needed - No.12 QTY 4

- No.13 QTY 3

- No.14 QTY 1

- No.20 QTY 2

- No.21 QTY 1

30mm

screw

SILICONE

SEALANT

P 7

Please retain product label and instructions for future reference

IMPORTANT: Pre-drill before xing screws.

Step 12

Parts Needed - No.15 QTY 3

- No.16 QTY 3

Fix the cover trims (No.15 and No.16)

to the corners and the joins of the

building, secure using 3x30mm for each

cover trim

18x30mm Screws

30mm

screw

Pre drill

hole

IMPORTANT: Pre-drill before xing screws.

Step 13

Parts Needed - No.17 QTY 4

- No.18 QTY 2

Fix the Fascias (No.17 and

No.18) to each side of the

building, secure using 3x30mm

Screws per fascia.

18x30mm Screws

30mm

screw

Pre drill

hole

Step 14

Parts Needed - No.10 QTY 1

- No.19 QTY 2

Fix the Door Beading strips (No.19)

to the door panel framing, secure

using 4x30mm Screws per strip.

Fix the door block (No.10) onto the

door framing using 2x50mm Screws

8x30mm Screws

2x50mm Screws

30mm

screw

Pre drill

hole

50mm

screw

IMPORTANT: Pre-drill before xing screws.

22 23

Pre drill

hole

50mm

screw

Fix the Turn Buttons (No.22) to the

door panel, ensuring that the turn

buttons catch the door, secure using

2x30mm screws

Fix the Hasp and Staple (No.23) onto

the door and door panel, secure using

7x30mm screws, ensuring the screws

go through the framing

9x30mm Screws

Step 17

Parts Needed - No.22 QTY 2

- No.23 QTY 1

IMPORTANT: Pre-drill before xing screws.

Please retain product label and instructions for future reference

P 8

It is ESSENTIAL that you apply wood

treatment immediately after the building

has been assembled.

AFTER TREATMENT:

score around protective

cover on glazing and

carefuly peel

covering back

P 7











































































































































4



















P 8







































¡











2





































Inhaltsverzeichnis

Andere Mercia Garden Products Gartenhaus Handbücher

Mercia Garden Products

Mercia Garden Products 01DTSHAX0608SDFW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 02CHY0404-V3 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 03DTSHRA0808FGC42TW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 0634AXNE0503HGDD2MW-V1 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 01PTOSBA1008DDFW-V2 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 03DTSHCR0808FGD2TW-V2 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 03DTSHCR0707FGD2TW-V2 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01GRO0705-V2 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 0619PNNE0324HGDD2SW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01DTPRMSHPN1008DDOP-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01DTSHPN0806SDFW-V1 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 01GRODB0808-V3 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 0634RANE0504FGDD2TW1SW-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01OVLPA1010DDFW-V1 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 01DTPRMSHPN1208DDOP-V2 Bedienungsanleitung

Mercia Garden Products

Mercia Garden Products 01DDPENT1008-V3 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01RAW2010DDOW-V3 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 06LOG004-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 02HIDE0705-V1-PEFC Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 03TGCOR0707-V5 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 03VER1008-V2 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 0628LOG175-V4 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01DTPRMSHPN1208DDOP-V1 Gebrauchsanweisung

Mercia Garden Products

Mercia Garden Products 01PTJER0806-V1 Gebrauchsanweisung

Beliebte Gartenhaus Handbücher anderer Marken

Lemeks

Lemeks Palmako PA120-5930-6 Installationshandbuch

Rion

Rion Hobby Gardener Bedienungsanleitung

Gartenhaus-King

Gartenhaus-King Valery Bedienungsanleitung

Select

Select ISAAC E9682 Bedienungsanleitung

Palmako

Palmako Saale Bedienungsanleitung

Lemeks

Lemeks Palmako Kira EL16-3623 Installationshandbuch

Palmako

Palmako Roger FR44-5953-2 Bedienungsanleitung

Pergola kits USA

Pergola kits USA PREMIUM VINYL PAVILION Bedienungsanleitung

G21

G21 Boston 882 Bedienungsanleitung

Lemeks

Lemeks Palmako Grace PM56-4529 Installationshandbuch

Shire

Shire Salcey Bedienungsanleitung

Rutland County

Rutland County Burley 6ft Bedienungsanleitung

Palmako

Palmako Roger 27,7 Bedienungsanleitung

Lemeks

Lemeks Palmako PA120-5930-9 Installationshandbuch

Lemeks

Lemeks Palmako PM70-6436 Installationshandbuch

Lemeks

Lemeks Palmako PM56-4435 Installationshandbuch

Lemeks

Lemeks 106214 Installationshandbuch

POD

POD Camping 480 Bedienungsanleitung