Town & Country Fireplaces TC42 Bedienungsanleitung

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

These instructions are supplementary to the Installation and

Operating Instructions supplied with the replace and should be

kept together. Refer to the Installation and Operating Instructions

for proper gas supply, safety requirements and operating

instructions

Visit www. townandcountryﬁreplaces.net for the most recent version of this manual

160223-16 SKU# 22150035 100000383

TC42

BLACK DIAMOND

BURNER KIT

INSTALLATION

INSTRUCTIONS

SKU# 22150035

For TC42 Series D

Fireplaces

Figure 1: Contents of kit.

Figure 2: Attaching the manifold assy.

Contents of Package

Burner Installation

2SKU# 22150035_160223-16

100000383

• BURNER

• BURNER TRAY ASSEMBLY

• TUMBLED GLASS

• BURNER SHIELD

• MANIFOLD ASSEMBLY

(including supply tube)

• PILOT SHIELD

(including pilot and pilot

supply tube)

• HARDWARE PACKAGE

• MEDIA SPACER, rear

• MEDIA SPACER, front

• MEDIA SPACER, center

NOTE: MUST BE USED WITH PORCELAIN PANELS #TC42.PNLPBKB

A porcelain panel set must be used in conjunction with the installation of the burner assembly. See Installation

and Operating Instructions manual for details.

1. Remove the three lower screws

from the air channel at the back

of the rebox and attach the

manifold assembly to the back

of the rebox (Figure 2).

SKU# 22150035_160223-16 100000383

2. Attach the manifold and pilot

supply tubes to the bulk head

tting and tighten (Figure 3).

Ensure that all connections are

gas tight.

3. Feed the ignition and sensor

wires through the bulkhead

plate (Figure 3) to the interface

Figure 3: Gas and pilot supply tubes.

Ignition and sensor wires

Bulkhead plate

Figure 4: Ignition and sensor wires routing.

Figure 6: Panel clips.

4SKU# 22150035_160223-16

100000383

Ignition wire (red)

Flame sensor

wire (white)

Interface module

Figure 5: Interface module.

4. Attach the ignition and sensor

wires to the module (Figure 5).

5. Panel clips must be installed

on the bottom of both side

panels (notch facing inside)

(Figure 6). To ensure proper

positioning of the burner

shield. This must be done at

the same time as installing the

porcelain side panels.

6. Install rear panel of porcelain

panel set. The base panel of

the porcelain panel set is not

used with the Black Diamond

installation, and may be dis-

carded.

Burner shield

Figure 7: Installing burner shield.

Figure 8: Positioning clip nuts.

SKU# 22150035_160223-16 100000383

7. Install burner shield by tip-

ping the shield into the rebox,

catching the folded edges in

the panel clips (Figure 7).

8. Position clip nuts, included

in hardware package, onto

burner shield (Figure 8).

Figure 9: Installing burner tray.

Figure 10: Installing pilot sheild.

6SKU# 22150035_160223-16

100000383

9. Attach the burner tray to the

burner shield using two screws

at the back of the tray

(Figure 9)

10. Attach pilot shield to burner

tray with two screws.

(Figure 10)

Rear media spacer

Figure 11: Rear media spacer.

Front media spacer

Figure 12: Front media spacer.

SKU# 22150035_160223-16 100000383

11. Install front & rear media spac-

ers (Figure 11 and Figure 12).

12. Set the burner air shutter to

fully open for propane or fully

closed for natural gas.

Figure 13: Installing burner.

Figure 14: Burner installed.

8SKU# 22150035_160223-16

100000383

13. Install burner by tilting burner

inlet through tray. Ensure that

the orice has entered the inlet

tube (Figure 13 and Figure 14) .

Center media spacer

Figure 15: Center media spacer.

Figure 16: Applying glass media.

SKU# 22150035_160223-16 100000383

14. Install the center media spacer

and secure spacer to the tray

with the two long screws pro-

vided. (Figure 15).

15. Apply just enough glass media

to cover the burner assembly.

(Figure 16)

NOTE: Too much glass media

over the burner will cause

sooting with the use of pro-

pane gas.

Unit is designed specically

to use glass media part #

5012.01.

Use of any other glass or

material will void warranty.

WARNING

This conversion kit shall be installed by a qualiﬁed service agency in accordance with the manufac-

turer's instructions and all applicable codes and requirements of the authority having jurisdiction.

If the information in these instructions is not followed exactly, a ﬁre, explosion or production of car-

bon monoxide may result causing property damage, personal injury or loss of life.

The qualiﬁed service agency is responsible for the proper installation of this kit. The installation is

not proper and complete until the operation of the converted appliance is checked as speciﬁed in

the manufacturer's instructions supplied with the kit.

CAUTION

The gas supply and electrical power shall be shut off before proceeding with the conversion.

Note: Factory supplied components must be used to ensure correct input. After conversion, conrm proper

manifold pressure.

1. Ensure the burner, pilot and gas supply are turned off, and the appliance has cooled.

2. With a ½” wrench remove the natural gas orice (Figure 17) and replace with propane orice included in

the SIT conversion kit.

3. Fully open the primary air shutter (Figure 18).

4. Remove the pilot shield from the burner tray by removing two screws (Figure 19).

5. With a 7/16” wrench loosen the pilot head on the pilot assembly by a half-turn (Figure 20).

6. Slide the pilot adjustment band over and ensure that the hole in the orice band is showing. (Figure 21

indicates NG position, Figure 22 indicates LP position)

Figure 17: Replacing the orice.

Primary air shutter

Figure 18: Primary air shutter.

Propane Conversion

10 SKU# 22150035_160223-16

100000383

Andere Handbücher für TC42

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Town & Country Fireplaces Kamin im Innenbereich Handbücher

Town & Country Fireplaces

Town & Country Fireplaces TC30D2 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC54.NG03C2 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 TC36ST.NGST03D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30.NG02CN Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54NG03C2 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCW120 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.CE3 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.NGST04C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36.NGST03 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCW120 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC54.LP02.C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.38CE3 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54ST SERIES D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC36 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54DST Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS38 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS54D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCVT.FMPV3 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54NG04.C2 Technisches Handbuch

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch